Abstract:There are heat transfer correlations for heat transfer analysis in single tube geometries after several experimental and theoretical heat transfer studies in these single tube geometries. This is not the case for heat transfer analysis in rod bundle geometry with regard to proposed square fuel assembly of the Supercritical-Water-Cooled Reactor (SCWR) European Atomic Energy (EURATOM) design. Thus limited heat transfer studies exist on rod bundle geometry at supercritical pressures. Heat transfer correlations with accurate prediction capabilities of coolant and wall temperatures will be helpful in carrying out heat transfer studies at supercritical pressures. This paper presents the performance of twelve selected heat transfer correlations assessed on the 1/8th bare square fuel assembly of the SCWR EURATOM design using Simulation of Turbulent flow in Arbitrary Regions Computational Continuum Mechanics C ++ based code (STAR-CCM + CFD code). The obtained numerical results were compared with the results obtained by Waata numerical experimentation. Overall, the Cheng et al. correlation provided the most satisfying prediction for the wall temperatures in all the sub-channels and captured closely Wataa's Numerical data. The maximum wall temperature was obtained in sub-channel 9, the hottest sub-channel and exceeded the design limit 620 °C by 60 °C for the Cheng correlation. The difference in temperature between the hottest and coldest sub-channels 9 and 1 respectively was approximately 80 °C. It was found that Cheng correlation is best suited for heat transfer prediction in rod bundle geometry at supercritical pressures with regard to the proposed square fuel assembly of the SCWR EURATOM design. It was also found that the different numerical tools adopted for this study and Waata study were able to capture the trends of normal, enhanced and deteriorated heat transfer regimes normally observed at supercritical pressures. Nevertheless, experimental investigations involving rod bundles adopted in this study should be conducted to validate the results obtained numerically and address the inconsistency of the conclusions drawn when compared with Waata data and other similar studies.

Assessment of Nucleate Boiling Correlations Applied to Thermal-hydraulic Code of Reactor

Assessment of Nucleation Boiling Models and Improvement by the Chen Correlation for Two-fluid Model CFD

Nonuniform Heat Transfer of Supercritical Water in a Tight Rod Bundle – Assessment of Correlations

Assessment of Heat-Transfer Correlations Against Experimental Data Obtained with Supercritical Water in Vertical Annuli

Assessment of two-phase heat transfer coefficient and critical heat flux correlations for cryogenic flow boiling in pipe heating experiments

Assessment of heat transfer correlations in the sub-channels of proposed rod bundle geometry for supercritical water reactor

A Correlation Of Heat Transfer Non-Uniformity In Rod Bundle And Its Application To Sub-Channel Code

Analysis of Heat Transfer Characteristics in Core of Supercritical Water Cooled Reactor

Assessment of existing two phase heat transfer coefficient and critical heat flux correlations for cryogenic flow boiling in pipe quenching experiments

Quantitative Evaluation of Uncertain Parameters for Thermal-Hydraulic Experiments Based on the COSINE Code

An Assessment of Heat Transfer Models of Water Flow in Helically Coiled Tubes Based on Selected Experimental Datasets

DEVELOPMENT OF A THERMAL-HYDRAULIC ANALYSIS CODE FOR HELICAL COILED ONCE THROUGH STEAM GENERATOR

High‐heat Flux Flow and Heat Transfer Transitions in a Supercritical Loop: Numerical Verification and Correlation

Investigation And Modeling Of The In-Tube Heat Transfer Of Fluids At Supercritical Pressure During Heating

NEW FLOW-PATTERN-BASED HEAT TRANSFER CORRELATIONS FOR WATER IN MICRO/MINICHANNELS

Effect of Circumferential Flow Non-uniformity on the Temperature Distribution of Membrane Water Wall in Supercritical Boilers and Simplified Calculation Methods

Assessment Of Performance Of Turbulence Models Of Cfx In Predicting Supercritical Water Heat Transfer In A Vertical Tube

A New Correlation For Heat Transfer Coefficient Prediction Of Supercritical Pressure Water Flowing In Vertical Upward Tubes

Saturated nucleate pool boiling of cryogenic fluids: Review of databases, assessment of existing models and correlations, and development of new universal correlation

Numerical Study on the Thermohydraulics of Near-Critical Water in Rod Bundle with Spacer Grids

A Method of Extending Subcritical Heat Transfer Correlations to Supercritical Conditions