Abstract:Due to the impact of global warming and climate change, more and more people are starting to have a clearer understanding and vigilance about greenhouse gases. To prevent further deterioration of the global environment, this study examines the coefficients of performance of 21 currently available refrigerants with very low global-warming potential and zero ozone-depleting potential under evaporation temperatures of 10, −20, −40, and −60 °C and condensation temperatures of 30, 40, and 50 °C, respectively. It is found that the use of pure refrigerant in a two-stage refrigeration system to replace the single-stage refrigeration system, in addition to mixing it into an appropriate mixture, can effectively improve the performance coefficient of the refrigeration system. For single-stage vapor compression refrigeration systems, R1234ze(Z), R601, and R1233zd(E) have the best refrigeration performances among the environmentally friendly refrigerants studied, while R441A performs the worst for Teva = 10 °C and −20 °C. Moreover, RE170 has the highest COP of the refrigeration system for Teva = −40 °C and −60 °C. However, R1234yf performs worse in COP when the evaporation temperature is lower, and it ranks last for Teva = −60 °C. When a double-stage vapor compression refrigeration system is employed instead, the percentage increase in the COP of the system using R1234yf becomes the largest for Teva = −40 °C and −60 °C. However, the growth rate of R717 ranks last for Teva = −60 °C. For an R717/R1234yf mixture at an optimum mass fraction of 0.25, the COP of the refrigeration system can be increased up to 25.8% despite an increase of 15.2% in operating pressure compared to R1234yf. The discharge temperature may rise; however, there will be no overheating problem for the compressor.

Heating performance comparison of different heat pump refrigerants at low temperature

A thermodynamic analysis of a transcritical cycle with refrigerant mixture R32/R290 for a small heat pump water heater

Study on the Performance of a Novel Waste Heat Recovery System at Low Temperatures

Refrigerants And Heat Pumps For Efficient Use Of Low Grade Thermal Energy

Experimental Investigations on the Performance of a Single-Stage Compound Air-Source Heat Pump Using CO2/R600a in Cold Regions

Experimental and Theoretical Assessments on the Systematic Performance of a Single-Stage Air-Source Heat Pump Using Ternary Mixture in Cold Regions

Comparison of Cycle Performance of HFO-1336mzz(Z)and HCFC-123 in Heat Pump System

Experimental Research on Cooling/Heating Performance Using R1234yf and R134a

Experimental Research on Quasi Two-stage Compression Heat Pump with Flash Tank Vapor-injection Using R134a

Theoretical Investigation and Comparative Analysis of the Linde–Hampson Refrigeration System Using Eco-Friendly Zeotropic Refrigerants Based on R744/R1234ze(Z) for Freezing Process Applications

Experimental Research on -60℃ Refrigerator

Vapor injected heat pump using non-azeotropic mixture R 32 / R 1234 ze ( E ) for low temperature ambient

Performance of a Single-Stage Linde-Hampson Refrigerator Operating with Binary Refrigerants at the Temperature Level of −60 °C

Performance Evaluation of Centrifugal Refrigeration Compressor Using R1234yf and R1234ze(E) as Drop-In Replacements for R134a Refrigerant

Investigations on Performance of an Auto-Cascade Absorption Refrigeration System Operating with Mixed Refrigerants

Experimental performance of moderately high temperature heat pump with working fluid R1234ze(Z)

Theoretical study of low-GWP refrigerants in high-temperature heat pump systems

Experimental Testing of a Water-to-Water Heat Pump with and without IHX by Using Refrigerants R1234yf and R1234ze(E)

Simulations and experiments of substitution of R41 for R23 in auto-cascade refrigeration cycle with rectifying column at -60℃

Experimental Evaluation on Low Global Warming Potential HFO-1336mzz-Z As an Alternative to HCFC-123 and HFC-245fa

Performance Enhancement Analysis of Environmentally Friendly Refrigerants