Abstract:Copper intrauterine device is one of the most adopted contraceptive methods with high effectiveness (over 99 %), low cost, spontaneous reversibility and long-lasting usage. However, the side effects induced from the initial burst release of copper ions (Cu2+) hinder the continuation of the Cu-IUD made of Coarse-Grained Copper (CG Cu). We proposed to tailor the bio-corrosion behaviors of better control of Cu2+ release via the addition of bioactive Mg into the Ultra-Fine Grained (UFG) Bulk Cu. Thus, UFG bulk Cu with 0.4 wt.% Mg was produced via equal-channel angular pressing. The microstructures of the UFG Cu-0.4Mg was observed using electron backscatter diffraction and transmission electron microscopy techniques. The in vitro long-term corrosion behaviors in simulated uterine fluid, cytotoxicity to four cell lines, in vivo biocompatibility and contraceptive efficacy were all studied on CG Cu, UFG Cu and UFG Cu-0.4Mg materials. The results demonstrate that both the ultrafine grains and the addition of bioactive Mg into Cu contribute to the suppression of the burst release of Cu2+ in the initial stage and the maintenance of high level Cu2+ in long-term release. Moreover, the UFG Cu-0.4Mg also exhibited much improved cell and tissue biocompatibility from both the in vitro and in vivo evaluations. Therefore, the contraceptive efficacy of UFG Cu-0.4Mg is still maintained as high as the CG Cu and UFG Cu while the side effects are significantly eased, suggesting the high potential of the UFG Cu-0.4Mg alloy as a new upgrading or alternative material for Cu-IUD.<h3 class="u-h4 u-margin-m-top u-margin-xs-bottom">Statement of significance</h3>The side effects from burst release of Cu2+ at the initial implantation stage of Cu-containing intrauterine devices (Cu-IUD) is one of the main drawbacks of these devices. In this work, an ultra-fine-grained Cu (UFG Cu) alloyed with a low amount of bioactive Mg was used for a Cu-IUD. The UFG Cu-0.4Mg alloy exhibited suppressed burst release of Cu2+ at initial implantation, while active Cu2+ release for long-term usage was maintained, comparable to coarse-grained pure Cu. Furthermore, the UFG Cu-0.4Mg alloy displayed significantly improved biocompatibility with human uterus cells and a much decreased inflammatory response within the uterus. Therefore, the side effects from Cu-IUD were eased, while high antifertility efficacy of the UFG Cu-0.4Mg alloy was maintained. The UFG Cu-0.4Mg alloy is promising for Cu-IUD.

Tandem Mass Tag‐based Quantitative Proteomic Profiling of the Serum of Patients with Abnormal Uterine Bleeding Associated with Copper Intrauterine Device

Associations of <i>MCM8</i> rs3761873 and rs16991617 variants with abnormal uterine bleeding induced by copper intrauterine device

Whole-exome sequencing reveals novel variants associated with abnormal uterine bleeding caused by copper intrauterine device

Clinical Utility of Serum Reproductive Hormones for the Early Diagnosis of Ectopic Pregnancy in the First Trimester.

Copper levels in cervical mucus of copper intrauterine device users versus non‐users

Label-free Proteomics Uncovers SMC1A Expression is Down-regulated in AUB-E

Cu Ion Release and Cell Damage Effect of Cu-Containing Iuds with Different Surface Areas of Copper

Feasibility evaluation of a Cu-38 Zn alloy for intrauterine devices: In vitro and in vivo studies

Reproductive outcomes following copper‐containing intrauterine device after hysteroscopic lysis for intrauterine adhesions

The Testing of Copper Intrauterine Devices to Mitigate Uterine Infections in Mares: A Preliminary Study

Chronic Systemic Toxicity Study of Copper Intrauterine Devices in Female Wistar Rats.

Concentration-dependent Cytotoxicity of Copper Ions on Mouse Fibroblasts in Vitro : Effects of Copper Ion Release from TCu380A Vs TCu220C Intra-Uterine Devices

Effective Inhibition of the Early Copper Ion Burst Release with Ultra-Fine Grained Copper and Single Crystal Copper for Intrauterine Device Application

Bleeding Pattern Difference Between Levonorgestrel Intrauterine System and Copper Intrauterine Devices Inserted Immediately Post-Abortion: a Multicenter, Prospective, Observational Cohort Study in Chinese Women.

Effects of A Novel Complexing Copper-containing IUD on Endometrial Morphology in Rats

Effective easing of the side effects of copper intrauterine devices using ultra-fine-grained Cu-0.4Mg alloy

Mitigating Adverse Effects of Cu-containing Intrauterine Devices Using A Highly Biocompatible Cu-5Fe alloy

The contradictive findings between ultrasound, hysteroscopy and cytokines in women with nonhormonal IUDs suffering from menorrhagia: a prospective study

[Analysis the Cupric Ion Release Characteristics of Different Copper Raw Materials in Intrauterine Device in Vitro Using ICP Method].

Corrosion of wire and tube of copper-bearing intrauterine device in simulated uterine solution

Urine Proteomics Differentiate Primary Thrombotic Antiphospholipid Syndrome From Obstetric Antiphospholipid Syndrome