Abstract:In this study, a novel sol-gel method is used to synthesize amorphous silica-alumina materials with a narrow mesoporous distribution and various Si/Al molar ratios without using any templates and pore-regulating agents. During the preparation procedure, only inexpensive inorganic salts were used as raw materials, instead of expensive and harmful alkoxides. The precursor sol was dried at room temperature in a vacuum box kept at 60 mmHg until it began to form the gel. The results of a nitrogen sorption experiment indicate that the synthesized materials with different Si/Al molar ratios have similar mesoporous distributions (within 2-12 nm). Moreover, it was found that the material's pore size distribution remains at a similar value during the heat treatment from room temperature to 550 degreesC. On the basis of the nitrogen sorption, TEM, and AFM characterization results, a formation mechanism of mesopores which accounts for the experimental data is also suggested. This suggested mechanism involves rearrangement of the primary particles during the drying process to form the precursors of the similarly sized mesopores. The synthesized materials were characterized by XRD, thermal analysis (TG/DTA), Al-27 and Si-29 MAS NMR spectroscopy, SEM, TEM, and AFM. The results of Al-27 and 29Si MAS NMR indicate that the distribution of silicon and aluminum in the synthesized materials is more uniform and homogeneous than that in the mixed oxides prepared via the traditional sol-gel method even at high alumina contents. The type and density of the acid sites were studied using pyridine adsorption-desorption FTIR spectroscopy. It was shown that the acidity of the synthesized materials is higher than that of the silica-alumina materials prepared by conventional methods.

Comparison of different gel routes used to synthesize Li2O-Al2O3-SiO2 powders

PREPARATION OF ULTRAFINE Li2O-Al2O3-SiO2 GLASS-CERAMIC POWDERS BY POLYACRYLAMIDE GEL METHOD

Preparation of nanoscale Li2O-Al2O3-SiO2 glass-ceramic by polyacrylamide gel method

A Novel Method To Synthesize Amorphous Silica−Alumina Materials with Mesoporous Distribution without Using Templates and Pore-Regulating Agents

Preparation and Crystallization of Si-Al Gel

Comparison of preparation and formation mechanism of LuAG nanopowders using two different methods

Preparation of Rare Earth/Alkaline Earth Composite Silicates Nanopowder by Water-Based Sol-Gel Method

Synthesis of Nano-Alumina Hydroxide Sol Using Sol-gel Method

Effects of the synthesis hydrogel on the formation of zeolite LTA membranes

Preparation of Β-Spodumene-based Glass–ceramic Powders by Polyacrylamide Gel Process

The Synthesis and Characterization of SiO_2-Al_2O_3 Xerogels

Effect of ZrO_2 on crystallization behavior of lithium aluminosilicate glass-ceramic powders by polyacrylamide gel method

Synthesis, solubility and thermodynamic properties of N-A-S-H gels with various target Si/Al ratios

Synthesis and structural characterization of SiO2-Al 2O3 xerogels

Preparation of Al2O3-2SiO2/geopolymer Powder by Hydrolytic Sol-Gel Method and Its Activity Characterization and Research on the Reaction Mechanism

Al2O3 XEROGELS SYNTHESIZED BY INORGANIC SALT AND ORGANIC ALKOXIDE

Influence of La2O3 on Properties of Li2O-Ai2O3-SiO2 System Glass-Ceramics

In-Situ Control of CaO-MgO-SiO2 Nanoparticles Synthesized by the Sol-Gel Method

Effect of Zro2 on Crystallization Behavior of Lithium Aluminosilicate Glass-Ceramic Powders by Polyacrylamide Gel Method

Synthesis and characterization of sol-gel derived continuous spinning alumina based fibers with silica nano-powders

Synthesis and Structural Characterization of SiO<sub>2</sub>-Al<sub>2</sub>O<sub>3</sub> Xerogels