Abstract:An industrial demonstration unit using natural gas as a heat source was built to calcine the by-products of MgO wet flue gas desulfurization from power plants; influencing factors on the SO2 content in calciner gas were comprehensively analyzed; and an advantageous recycling condition of MgO and SO2 from by-products was summarized. Results showed that the SO2 content in the calciner gas was increased by more than 10 times under a lower excess air coefficient, a higher feed rate, a lower crystal water in by-products, and a higher feed port position. For the tests conducted under the excess air coefficient above and below one, the effect of the furnace temperature on the SO2 content in the calciner gas was reversed. Results of activity analysis indicate that particles of MgO generated under the calcination temperature of 900-1,000°C had a high activity. In contrast, due to the slight sintering, MgO generated under the calcination temperature of 1,100°C had a low activity. To recycle SO2 as well as MgO, a temperature range of 900-927°C for TE103 is proposed. These studies will prompt the desulfurization market diversification, reduce the sulfur's dependence on imports for making sulfuric acid, be meaningful to balance the usage of the natural resource in China, and be regarded as a reference for the development of this technology for other similar developing countries.

Retracted: Study on Magnesia Flue Gas Desulfurization (retracted Article)

Study on the Reaction Characteristics of Flue Gas Desulfurization by Magnesia

Study on the characteristics of flue gas desulfurization by magnesium oxide

Research on Sulfur Recovery from the Byproducts of Magnesia Wet Flue Gas Desulfurization

Studies on Magnesium-Based Wet Flue Gas Desulfurization Process with Oxidation Inhibition of the Byproduct

D214 STUDY ON THE INFLUENCING FACTORS OF FLUE GAS DESULFURIZATION BY MAGNESIA(Environmental Protection-3)

Mechanism and technology of recovery flue gas desulphurization with magnesium oxide

Experiment and Mechanism Analysis of Desulfurization with a MgO-Based Desulfurizer Fixed Bed Method

Studies on Magnesium-Based Wet Flue Gas Desulphurization Process with a Spray Scrubber

Optimization of pyrolysis for MgO recycling in magnesia-based flue gas desulfurization

Research on Recovery of MgO by Desulfurization By-Product of Magnesium Oxide

Modeling and application of processes of magnesia flue gas desulfurization

STUDY ON THE INFLUENCE OF MAGNGNE SIUM OXIDE UPON QUALITY OF HYDRATED LIME IN DRY FGD SYSTEM

The Kinetics of Oxidation Inhibition of Magnesium Sulfite in the Wet Flue Gas Desulphurization Process

Recovery of SO2 and MgO from By-Products of MgO Wet Flue Gas Desulfurization.

Kinetics and Mechanism of Sulfite Oxidation in the Magnesium-Based Wet Flue Gas Desulfurization Process

Technical and economic feasibility analysis of recovery flue gas desulphurization with magnesium oxide

Study on kinetics of flue gas desulfurization with pyrolusite slurry

Dynamic study on desulphurization reaction of MgO-CaO refractories

Magnesia reactivity on activating efficacy for ground granulated blastfurnace slag for soft clay stabilisation

Assessing Magnesia Effect on Preparing Refractory Materials from Ferrochromium Slag