Abstract:The phase equilibrium of Mg-Cu-Ca ternary system at 350 degrees C were investigated using thirteen key samples. Scanning electron microscopy (SEM) equipped with energy-dispersive spectroscope (EDS) was employed to investigate equilibrium relationships and phase compositions in alloy samples. Powder X-ray diffraction (XRD) technique was used to analyze the crystal structures of new found phases. Two unreported ternary phases, P1 and Mg25-xCu75Cax were observed and investigated for the first time. The compound P1 has a narrow solid homogeneity ranged from about Mg25Cu35Ca40 to Mg30Cu30Ca40 (in at. %). The solid solubility limit of the compound Mg25-xCu75Cax was found to be 8.03 <= x(Ca) <= 16.67 with constant value of about 75 at. % Cu at 350 degrees C. The 2q of fourteen diffraction peaks of new phase P1 were determined to be 23.0 degrees, 35.9 degrees, 37.3 degrees, 38.9 degrees, 42 degrees, 44 degrees, 47 degrees, 52.5 degrees, 54 degrees, 56.7 degrees, 62.3 degrees, 66.8 degrees, 68.2 degrees and 75.4 degrees. The 2q of ten diffraction peaks of the new compound Mg25-xCu75Cax were confirmed to be 20.5 degrees, 21.2 degrees, 34.7 degrees, 35.7 degrees, 42.3 degrees, 43.3 degrees, 44.8 degrees, 47.3 degrees, 50.5 degrees and 74.5 degrees. The maximum solid solubility of Ca in the terminal compound MgCu2 was found to be 8.83 at. % at 350 degrees C. Ternary maximum solid solubility of binary terminal compounds Mg2Ca, Mg2Cu, Cu5Ca and CuCa were less than 2 at. %. In addition, eight three-phase equilibrium relationships were determined in the present work. (C) 2019 Elsevier B.V. All rights reserved.

Phase Equilibria of the Al-Rich Corner in the Al-Cu-Fe-Si System at 650 A degrees C

Phase Equilibria of the Sn-Ag-Cu-Ni Quaternary System at the Sn-Rich Corner

Experimental determination of the phase equilibria of aluminum-rich Al−Li−Cu alloys

Phase Relationships in the Al-rich Region of the Al-Y-Zr System

Calculation of Phase Diagrams and Solidification Paths of Al-rich Al−Li−Cu Alloys

Multi-component Phase-Field Simulation of Microstructural Evolution and Elemental Distribution in Fe–Cu–Mn–Ni–Al Alloy

Phase equilibria in Co−Al−Re ternary system at 1100 and 1300 °C

The Effects of Si and Al Alloying on α/γ Phase Equilibria in Fe-Cr-Ni-Mn Based Ternary and Quaternary Systems

Microstructure and Mechanical Behavior of Quaternary Eutectic α+θ+Q+Si Clusters in As-Cast Al-Mg-Si-Cu Alloys

Experimental study of the phase relations in the Fe–Cr–Si ternary system at 700°C

Experimental Determination of the Phase Equilibrium in the Mg–Cu–Ca Ternary System at 350 °C

Phase Equilibria of the Sn–Zn–Cu Ternary System

Revealing the nucleation and growth mechanisms of Fe-rich phases in Al–Cu–Fe(-Si) alloys under the influence of Al–Ti–B

Effect of Si on Phase Equilibria, Mechanical Properties and Tribological Behaviour of Al-Cu Alloy

Phase Equilibria of the Sn-Ag-Cu-Ni Quaternary System at 210°C

Solidification paths and phase equilibria at 873 and 673 K in the Al-Er-Zr system

Phase Equilibria in the Au-Cu-In-Pd System at 500 °C and 800 °C: Experimental Study and Modeling

Phase Diagrams and Elastic Properties of the Fe-Cr-Al Alloys: A First-Principles Based Study

Phase equilibria and wetting of Al–Co–Cu and Al–Co–Ni quasicrystals

Phase Equilibria of Sn-Co-Cu Ternary System

Phase Equilibria In The Fe-Nb-Zr Ternary System At 1,200 A Degrees C