Membrane Bioreactor Technology for Treatment and Reuse of Mixed Domestic Wastewater from Residential Areas
CHEN Hongbin,LI Chen,LIU Fuqiang,DAI Xiaohu
DOI: https://doi.org/10.3969/j.issn.0253-374x.2013.02.016
2013-01-01
Abstract:A pilot-scale anoxic/oxic membrane bioreactor(AO-MBR) in combination with the activated carbon filter and ultraviolet combined chlorine disinfection devices were installed to treat the mixed domestic wastewater in a residential area in north China.The objectives of the research were to investigate the reclaimed water qualities and optimize the main operating parameters,furthermore,to analyze the technical and economic suitability for treatment of the mixed domestic wastewater with grey water only.The results show that,when the mixed domestic wastewater(effluent of septic tank) is chosen for treatment,under the conditions of 8 h hydraulic retention time(HRT),mixed liquor suspends solids(ρMLSS) 3 500~7 500 mg·L-1,the effluent is colorless and odorless,the chemical oxygen demand(ρCOD),biochemical oxygen demand(ρBOD5) and ammonia nitrogen(ρNH3-N) are respectively below 30.0 mg·L-1,3.0 mg·L-1 and 3.0 mg·L-1,which can stably meet the GB/T 18920-2002,however,the total nitrogen(ρTN) and total phosphorus(ρTP) concentration of effluent can't meet the requirements of GB/T 18921-2002;While simulating the ρCOD∶ ρTN∶ ρTP ratio of the raw wastewater(influent of septic tank),under the conditions of 10 h hydraulic retention time,50 d sludge retention time,the recycling ratio 200%,ρMLSS 5 500~6 000 mg·L-1,the dosage of poly-aluminum chloride(ρPAC) 4~5 mg·L-1,the effluent quality is better than the GB/T 18920-2002 and the GB/T 18921-2002.To achieve the same reclaimed water quality,the mixed domestic wastewater treating process is more complicated than that of the grey water,at the same time,the operating cost is 0.32 Yuan·m-3 higher than the later.Therefore,from view of the economic and technical feasibilities,it should be taken into account the demand and potential usage of the reclaimed water,the local climate conditions during selecting a suitable wastewater collection and treatment system in residential areas.