Abstract:In addition to selective catalytic reduction (SCR) and selective non-catalytic reduction (SNCR) which are available to remove NO x from flue gas, oxidation method is receiving more and more attention because this method makes it possible to remove NO x and SO 2 from flue gas simultaneously by wet scrubbing. O 3 as a strong oxidant has a high oxidation capacity and it can oxide NO to N 2 O 5 which has a higher water solubility compared with NO 2 . However, it needs a long reaction time and the escape of unreacted ozone may cause secondary pollution. In this study, FeMnCo/Al 2 O 3 catalyst and FeMnCe/Al 2 O 3 catalyst were prepared and applied to enhance the deep oxidation of NO x with ozone and reduce O 3 slip. Effects of various operating parameters such as O 3 /NO ratio, gas residence time, and operating temperature were evaluated, and the results demonstrate that N 2 O 5 began to generate when O 3 /NO ratio was higher than 1.0 and increased with increasing O 3 /NO ratio. Little residual O 3 was formed in the presence of catalyst, while 350 ppm O 3 was measured at the outlet gas when O 3 /NO ratio was controlled at 2.0. The N 2 O 5 conversion efficiency increased with increasing gas residence time and operating temperature, and the highest N 2 O 5 conversion efficiency was achieved at 100°C. Furthermore, the conversion efficiency remained around 90% during 20 h operation over FeMnCe/Al 2 O 3 catalyst with an O 3 /NO ratio of 1.73, a gas residence time of 1.2 s, and a temperature of 100°C. On the other hand, the N 2 O 5 conversion efficiency remained around 80% during 3 h operation over FeMnCo/Al 2 O 3 catalyst. Overall, FeMnCe/Al 2 O 3 catalyst reveals good potential for deep oxidation of NO by O 3 and can be further developed as a viable catalyst for reducing NO emission from industries. Implications : In this study, FeMnCo/Al 2 O 3 catalyst and FeMnCe/Al 2 O 3 catalyst were applied to enhance the deep oxidation of NO into N 2 O 5 with O 3 . The catalysts can improve the conversion of NO into N 2 O 5 , shorten the reaction time and reduce the unreacted O 3 slip, which are beneficial to reduce the size of the reactor required and cost of APCDs (air pollution control devices) in practical application. This method can make it possible to simultaneously remove NO x and SO 2 from flue gas by wet scrubbing for reducing NO emissions from industries, especially small and medium scaled industries, to meet increasingly stringent emission standards.

Partial Oxidation of NO by H<sub>2</sub>O<sub>2</sub> and afterward Reduction by NH<sub>3</sub>-Selective Catalytic Reduction: An Efficient Method for NO Removal

Tailoring the Proceeding of the NH3-SCO and NH3-SCR Reactions over FeOx Catalysts by Modifying with NbOx

NO Selective Catalytic Reduction over Atom-Pair Active Sites Accelerated Via in Situ NO Oxidation

Wet Oxidation and Absorption Procedure for NOx Removal

Combination of Nonthermal Plasma and Low Temperature-C3h8-Selective Catalytic Reduction over Co-In/H-Beta Catalyst for Nitric Oxide Abatement

Substitution of WO3in V2O5/WO3–TiO2by Fe2O3for Selective Catalytic Reduction of NO with NH3

Deep oxidation of NO via catalytic ozonation

Selective Catalytic Removal of High Concentrations of NOx at Low Temperature

Removal of NOx with Selective Catalytic Reduction Based on Nonthermal Plasma Preoxidation

Removal of NOX Using Hydrogen Peroxide Vapor over Fe/TiO2 Catalysts and an Absorption Technique

Enhanced Catalytic Performance of V2O5–WO3/Fe2O3/TiO2microspheres for Selective Catalytic Reduction of NO by NH3

Investigation On The No Removal From Simulated Flue Gas By Using H2o2 Vapor Over Fe-2(Moo4)(3)

Removal of Dilute Nitric Oxide Using Cobalt Diethylenetriamine Solution under Aerobic Condition

Investigation of advanced NO oxidation process with the delivery of ·OH from thermal decomposition of H2O2

Ultraviolet-induced nitric oxide removal using H2O/O2 catalyzed by Fe/TiO2: Feasibility and prospect

Efficient Synergistic Catalysis of Chlorinated Aromatic Hydrocarbons and NOx over Novel Low-Temperature Catalysts: Nano-TiO2 Modification and Interaction Mechanism.

Beyond Purification: Highly Efficient and Selective Conversion of NO into Ammonia by Coupling Continuous Absorption and Photoreduction under Ambient Conditions.

Simultaneous Removal of NO and SO2 from Coal-Fired Flue Gas Based on the Catalytic Decomposition of H2O2 over Fe2(MoO4)3

A Superior Liquid Phase Catalyst for Enhanced Absorption of NO2 Together with SO2 after Low Temperature Ozone Oxidation for Flue Gas Treatment

Performance of V_2O_5-WO_3-MoO_3/TiO_2 Catalyst for Selective Catalytic Reduction of NO_x by NH_3

Room Temperature Efficient Reduction of NOx by H2 in a Permeable Compounded Membrane – Catalytic Reactor