Abstract:Sewage sludge incineration ash (SSIA) is rich in phosphorus (P), thus being considered as a reliable source of phosphorus recovery. Different P species behaved significant bioavailability. Based on this, a comprehensive investigation into the bioavailability transition path of P species during sewage sludge (SS) incineration was conducted. P predominantly existed in the form of inorganic phosphorus (IP) in SS with a higher concentration of non-apatite inorganic phosphorus (NAIP) and less concentration of apatite inorganic phosphorus (AP). During the SS incineration process, OP existed in the flocs and cell structures of SS underwent destruction, the released P then combined with metal elements such as Ca, Mg, Fe, and Al to form AP species (Ca/Mg-P) and NAIP species (Fe/Al/Mn-P), and the NAIP decomposition to release into gas phase. This was the initial step for enhancing the bioavailability of P species. As temperature increased and the incineration process progressed, the low-temperature-resistant NAIP dissociated, and the metal-binding sites of Al, Fe and Mn in NAIP species were gradually replaced by the Ca and Mg thus forming thermal stability AP species (Ca/Mg-P, such as CaHPO4, Ca2PO4Cl, and Mg3(PO4)2 et al.). This step was crucial for the bioavailability improvement of P species during the incineration process. Therefore, the IP proportions in TP were extremely high (>98%), and this value gradually increased as incineration temperature raised. The higher incineration temperature, the lower NAIP concentration and higher AP concentration. Besides, additives such as coal/rice husk/eggshell played a significant affect. Additives wither higher Ca content were inclined to react with P to form Ca/Mg-P (AP), while the presence of SO2 would react with Ca metals to form CaSO4 thus inhibiting the formation of AP species (such as CaHPO4 and CaPO4Cl). This results could provide theoretical support for the efficient and directional migration of P during sewage sludge incineration.

Improved removal of phosphorus from incinerated sewage sludge ash by thermo-chemical reduction method with CaCl<sub>2</sub> application

Novel recycling of phosphorus-recovered incinerated sewage sludge ash residues by co-pyrolysis with lignin for reductive/sorptive removal of hexavalent chromium from aqueous solutions

Transformation of phosphorus by MgCl2 and CaCl2 during sewage sludge incineration

A comparison between sulfuric acid and oxalic acid leaching with subsequent purification and precipitation for phosphorus recovery from sewage sludge incineration ash

Heavy metal removal and speciation transformation through the calcination treatment of phosphorus-enriched sewage sludge ash

Feasibility of wet-extraction of phosphorus from incinerated sewage sludge ash (ISSA) for phosphate fertilizer production: A critical review

Optimizing iron removal from sewage sludge ash for enhanced phosphate fertilizer bioavailability

Phosphorus (P) recovery and reuse as fertilizer from incinerated sewage sludge ash (ISSA)

Efficient and Selective Recovery of Iron Phosphate from the Leachate of Incinerated Sewage Sludge Ash by Thermally Induced Precipitation

Remove and Recover Phosphorus During Anaerobic Digestion of Excess Sludge by Adding Waste Iron Scrap

Selective Recovery of Phosphorus from the Leachate of Incinerated Sewage Sludge Ash Using the Zr-modified Acid-Leaching Residue As Adsorbent for Two-Fold Resource Utilization

Preparation of phosphorus containing products by co-incineration of sludge ash and calcium-based additives: Focusing one-step and multi-step method

Crystalline phase analysis and phosphorus availability after thermochemical treatment of sewage sludge ash with sodium and potassium sulfates for fertilizer production

Development of a novel phosphorus recovery system using incinerated sewage sludge ash (ISSA) and phosphorus-selective adsorbent

Selective recovery of high purity aluminium phosphate from incinerated sewage sludge ash with Zr-modified biochar

Phosphate recovery from sludge-incinerated ash by adsorption with hydrotalcite synthesized by metals in the ash

Immobilization of high-Pb contaminated soil by oxalic acid activated incinerated sewage sludge ash

Migration and transformation of phosphorus and toxic metals during sludge incineration with Ca additives

Bioavailability transition path of phosphorus species during the sewage sludge incineration process

On wet chemical phosphorus recovery from sewage sludge ash by acidic or alkaline leaching and an optimized combination of both

Enhanced immobilization of metal pollutants in sewage sludge ash (SSA)-cement pastes by calcium chloride and nitrate: Experimental and DFT studies