Abstract:The advantages and drawbacks of existing wet chemical phosphorus (P) recovery technologies, their applicability to different types of sewage sludge ash (SSA) and the role of the decay products of detergent zeolites as a source of reactive Al in SSA are analyzed. Since neither a purely acidic nor a purely alkaline treatment are able to provide satisfactory technical solutions a wet chemical phosphorus (P) recovery process for sewage sludge ashes (SSAs) is investigated in detail that is based on a sequential treatment of SSA with an acid and a base. As a result of an acidic pre-treatment, the P fraction of the raw SSA that was bound as - alkaline-insoluble - calcium phosphate (Ca-P) is converted into aluminum phosphate (Al-P). This newly formed Al-P can be easily dissolved via alkaline treatment and then easily separated from the alkaline leachate via precipitation of Ca-P. The Al-component can be reused as precipitant for P-removal in waste water treatment plants (WWTPs). The investigated process requires fewer chemicals than the direct acidic dissolution of all P-compounds contained in the SSA. This is due to the described rearrangement of the P component from Ca-P to Al-P. That such a rearrangement of P occurs indeed was confirmed through a combination of XRD, ICP and XRF analyses together with mass balance calculations. The present investigation proves that the process works for very different types of SSAs: For Al-rich SSAs that come from WWTPs where Al-salt is used for chemical P-removal the described sequential treatment process works best and yields P-recovery rates as high as 70-77%. But even for SSAs from WWTPs where only iron salt is used for chemical P-removal, a considerable amount of the reactive Al necessary for the described P-rearrangement is supplied by decay products of detergent zeolites, a hidden Al-source present in most SSAs produced in Europe.

Selective Recovery of Phosphorus from the Leachate of Incinerated Sewage Sludge Ash Using the Zr-modified Acid-Leaching Residue As Adsorbent for Two-Fold Resource Utilization

Selective recovery of high purity aluminium phosphate from incinerated sewage sludge ash with Zr-modified biochar

Facile preparation of dual La-Zr modified magnetite adsorbents for efficient and selective phosphorus recovery

Development of a novel phosphorus recovery system using incinerated sewage sludge ash (ISSA) and phosphorus-selective adsorbent

Efficient and Selective Recovery of Iron Phosphate from the Leachate of Incinerated Sewage Sludge Ash by Thermally Induced Precipitation

Phosphorus removal and recovery from wastewater by highly efficient struvite crystallization in an improved fluidized bed reactor

Feasibility of wet-extraction of phosphorus from incinerated sewage sludge ash (ISSA) for phosphate fertilizer production: A critical review

A comparison between sulfuric acid and oxalic acid leaching with subsequent purification and precipitation for phosphorus recovery from sewage sludge incineration ash

Phosphorus (P) recovery and reuse as fertilizer from incinerated sewage sludge ash (ISSA)

Phosphorus recovery and resource utilization from phosphogypsum leachate via membrane-triggered adsorption and struvite crystallization approach

Remove and Recover Phosphorus During Anaerobic Digestion of Excess Sludge by Adding Waste Iron Scrap

Phosphate recovery from sludge-incinerated ash by adsorption with hydrotalcite synthesized by metals in the ash

Optimization of struvite from sewage sludge ash as phosphorus source

Enhancing Phosphorus Recovery from Efficient Acidogenic Fermentation of Waste Activated Sludge with Acidic Cation Exchange Resin Pretreatment: Insights from Occurrence States and Transformation

Novel recycling of phosphorus-recovered incinerated sewage sludge ash residues by co-pyrolysis with lignin for reductive/sorptive removal of hexavalent chromium from aqueous solutions

Acid treatment enhances phosphorus release and recovery from waste activated sludge: Performances and related mechanisms

Assessment of a simple and replicable procedure for selective phosphorus recovery from sewage sludge ashes by wet chemical extraction and precipitation

Immobilization of high-Pb contaminated soil by oxalic acid activated incinerated sewage sludge ash

Recovering phosphorus as struvite from the concentrated solution produced by the alternating aerobic/anaerobic biofilm system

On wet chemical phosphorus recovery from sewage sludge ash by acidic or alkaline leaching and an optimized combination of both

Phosphorus recovery from municipal sludge-derived hydrochar: Insights into leaching mechanisms and hydroxyapatite synthesis