Abstract:Synthetic natural gas (SNG) production from syngas is under investigation again due to the desire for less dependency from imports and the opportunity for increasing coal utilization and reducing greenhouse gas emission. CO methanation is highly exothermic and substantial heat is liberated which can lead to process thermal imbalance and deactivation of the catalyst. As a result, conversion per pass is limited and substantial syngas recycle is employed in conventional processes. Furthermore, the conversion of syngas to SNG is typically performed at moderate temperatures (275-325 degrees C) to ensure high CH4 yields since this reaction is thermodynamically limited. In this study, the effectiveness of a novel integrated process for the SNG production from syngas at high temperature (i.e. 600 degrees C) was investigated. This integrated process consists of combining a CO methanation nickel-based catalyst with a high temperature CO2 capture sorbent in a single reactor. Integration with CO2 separation eliminates the reverse-water-gas shift and the requirement for a separate water-gas shift (WGS) unit. Easing of thermodynamic constraint offers the opportunity of enhancing yield to CH4 at higher operating temperature (500-700 degrees C) which also favors methanation kinetics and improves the overall process efficiency due to exploitation of reaction heat at higher temperatures. Furthermore, simultaneous CO2 capture eliminates greenhouse gas emission. In this work, sorption-enhanced CO methanation was demonstrated using a mixture of a 68% CaO/32% MgAl2O4 sorbent and a CO methanation catalyst (Ni/Al2O3, Ni/MgAl2O4, or Ni/SiC) utilizing a syngas ratio (H-2/CO) of 1, gas-hour-space velocity (GHSV) of 22,000 h(-1), pressure of 1 bar and a temperature of 600 degrees C. These conditions resulted in similar to 90% yield to methane, which was maintained until the sorbent became saturated with CO2. By contrast, without the use of sorbent, equilibrium yield to methane is only 22%. Cyclic stability of the methanation catalyst and durability of the sorbent were also studied in the multiple carbonation-decarbonation cycle studies proving the potential of this integrated process in a practical application. (C) 2013 Elsevier B.V. All rights reserved.

Methanation of Coke Oven Gas over Ni-Ce/γ-Al2O3 Catalyst Using a Tubular Heat Exchange Reactor: Pilot-scale Test and Process Optimization

Engineering MOx/Ni Inverse Catalysts for Low-Temperature CO2 Activation with High Methane Yields

Total methanation of syngas to synthetic natural gas over Ni catalyst in a micro-channel reactor

A Study on Activity of Coexistent CO Gas during the CO2 Methanation Reaction in Ni-Based Catalyst

Sorption-enhanced Synthetic Natural Gas (SNG) Production from Syngas: A Novel Process Combining CO Methanation, Water-Gas Shift, and CO2 Capture

Production of Synthetic Natural Gas by CO Methanation over Ni/Al2O3 Catalyst in Fluidized Bed Reactor

Low-temperature methanation of fermentation gas with Ni-based catalysts in a multicomponent system

Optimizing biogas methanation over nickel supported on ceria-alumina catalyst: Towards CO2-rich biomass utilization for a negative emissions society

Production of Syngas Via Partial Oxidation and CO2Reforming of Coke Oven Gas over a Ni Catalyst

Thermal management of natural gas production from coke oven gas by optimizing catalyst distribution and operation conditions

The Catalytic Methanation of Coke Oven Gas over Ni-Ce/Al2O3 Catalysts Prepared by Microwave Heating: Effect of Amorphous NiO Formation

Simultaneous production of syngas and carbon nanotubes from CO2/CH4 mixture over high-performance NiMo/MgO catalyst

Plasma-catalytic CO2 methanation over Ni supported on MCM-41 catalysts: Effect of metal dispersion and process optimization

Bimetallic Ni-Fe total-methanation catalyst for the production of substitute natural gas under high pressure

CO2 utilization via methanation using 40%Ni/CexCr1-xO2 as a novel catalyst: a comparative study of packed-bed and micro-channel reactors

Biomass Derived low concentration CO2 mixed Gas Combined Steam to Reform Methane through Ni based volcanic rock catalyst

Development of Highly Stable Ni-Al 2 O 3 Catalysts for CO Methanation

Reaction Characteristics of Ni-Based Catalyst Supported by Al2O3 in a Fluidized Bed for CO2 Methanation

Ni-Mn catalysts on silica-modified alumina for CO2 methanation

Efficient Way of Carbon Dioxide Utilization in a Gas-to-Methanol Process: From Fundamental Research to Industrial Demonstration

Direct biogas upgrading via CO2 methanation to high-quality biomethane over NiMg/CNT-SiO2 fiber catalysts