Abstract:In this study, the effect of the cell density of monolithic catalysts was investigated and further mathematically modeled on cordierite supports used in CO 2 methanation. Commercial cordierite monoliths with 200, 400, and 500 cpsi cell densities were coated by immersion into an ethanolic suspension of Ni/CeO 2 active phase. SEM–EDS analysis confirmed that, owing to the low porosity of cordierite (surface area < 1 m 2 g −1 ), the Ni/CeO 2 diffusion into the walls was limited, especially in the case of low and intermediate cell density monoliths; thus, active phase was predominantly loaded onto the channels' external surface. Nevertheless, despite the larger exposed surface area in the monolith with high cell density, which would allow for better distribution and accessibility of Ni/CeO 2 , its higher macro-pore volume resulted in some introduction of the active phase into the walls. As a result, the catalytic evaluation showed that it was more influenced by increments in volumetric flow rates. The low cell density monolith displayed diffusional control at flow rates below 500 mL min −1 . In contrast, intermediate and high cell density monoliths presented this behavior up to 300 mL min −1 . These findings suggest that the interaction reactants-catalyst is considerably more affected by a forced non-uniform flow when increasing the injection rate. This condition reduced the transport of reactants and products within the catalyst channels and, in turn, increased the minimum temperature required for the reaction. Moreover, a slight diminution of selectivity to CH 4 was observed and ascribed to the possible formation of hot spots that activate the reverse water–gas shift reaction. Finally, a mathematical model based on fundamental momentum and mass transfer equations coupled with the kinetics of CO 2 methanation was successfully derived and solved to analyze the fluid dynamics of the monolithic support. The results showed a radial profile with maximum fluid velocity located at the center of the channel. A reactive zone close to the inlet was obtained, and maximum methane production (4.5 mol m −3 ) throughout the monolith was attained at 350 °C. Then, linear streamlines of the chemical species were developed along the channel.

CO2 utilization via methanation using 40%Ni/CexCr1-xO2 as a novel catalyst: a comparative study of packed-bed and micro-channel reactors

Engineering MOx/Ni Inverse Catalysts for Low-Temperature CO2 Activation with High Methane Yields

Process Intensification of Methane Production via Catalytic Hydrogenation in the Presence of Ni-CeO2/Cr2O3 Using a Micro-Channel Reactor

CO2 Methanation on the Catalyst of Ni/MCM-41 Promoted with CeO2

Modeling and experimental analysis of CO2 methanation reaction using Ni/CeO2 monolithic catalyst

CO2 methanation over nickel-CeO2 catalyst supported on Al2O3: Different impregnation strategies and Ni-Ce ratios

Highly active Ni/CeO2/SiO2 catalyst for low-temperature CO2 methanation: Synergistic effect of small Ni particles and optimal amount of CeO2

Methanation of Coke Oven Gas over Ni-Ce/γ-Al2O3 Catalyst Using a Tubular Heat Exchange Reactor: Pilot-scale Test and Process Optimization

A detailed characterization study of Ni/CeO 2 catalysts identifies Ni availability as the primary factor affecting CO 2 methanation performance

Insight and comprehensive study of Ni-based catalysts supported on various metal oxides for CO2 methanation

Catalytic Performance for CO Methanation over Ni/MCM-41 Catalyst in a Slurry-Bed Reactor

A High Loaded Catalyst of Highly Dispersed Nickel Species on Acid-Treated Mesoporous Clay Layers for Efficient CO and CO2 Methanation

The Catalytic Methanation of Coke Oven Gas over Ni-Ce/Al2O3 Catalysts Prepared by Microwave Heating: Effect of Amorphous NiO Formation

A Study on Activity of Coexistent CO Gas during the CO2 Methanation Reaction in Ni-Based Catalyst

Aqueous Miscible Organic LDH Derived Ni-Based Catalysts for Efficient CO2 Methanation

Total methanation of syngas to synthetic natural gas over Ni catalyst in a micro-channel reactor

Combustion-impregnation preparation of Ni/SiO2 catalyst with improved low-temperature activity for CO2 methanation

Reaction Characteristics of Ni-Based Catalyst Supported by Al2O3 in a Fluidized Bed for CO2 Methanation

CO2 Methanation over CoNi Bimetal-Doped Ordered Mesoporous Al2O3 Catalysts with Enhanced Low-Temperature Activities

Highly active Ni/Al2O3 catalyst for CO2 methanation by the decomposition of Ni-MOF@Al2O3 precursor via cold plasma

Cobalt Supported Nickel Silicate Nanotubes for Efficient CO2 Methanation