Abstract:Gasifier-derived syngas from coal has many applications in the area of catalytic transformation to fuels and chemicals. Raw syngas must be treated to remove a number of impurities that would otherwise poison the synthesis catalysts. Inorganic impurities include alkali salts, chloride, sulfur compounds, heavy metals, ammonia, and various P, As, Sb, and Se- containing compounds. Systems comprising multiple sorbent and catalytic beds have been developed for the removal of impurities from gasified coal using a warm cleanup approach. This approach has the potential to be more economic than the currently available acid gas removal (AGR) approaches and improves upon currently available processes that do not provide the level of impurity removal that is required for catalytic synthesis application. Gasification also lends itself much more readily to the capture of CO2, important in the regulation and control of greenhouse gas emissions. CO2 capture material was developed and in this study was demonstrated to assist in methane production from the purified syngas. Simultaneous CO2 sorption enhances the CO methanation reaction through relaxation of thermodynamic constraint, thus providing economic benefit rather than simply consisting of an add-on cost for carbon capture and release. Molten and pre-molten LiNaKCO3 can promote MgO and MgO-based double salts to capture CO2 with high cycling capacity. A stable cycling CO2 capacity up to 13 mmol/g was demonstrated. This capture material was specifically developed in this study to operate in the same temperature range and therefore integrate effectively with warm gas cleanup and methane synthesis. By combining syngas methanation, water-gas-shift, and CO2 sorption in a single reactor, single pass yield to methane of 99% was demonstrated at 10 bar and 330°C when using a 20 wt% Ni/MgAl2O4 catalyst and a molten-phase promoted MgO-based sorbent. Under model feed conditions both the sorbent and catalyst exhibited favorable stability after multiple test cycles. The cleanup for warm gas cleanup of inorganics was broken down into three major steps: chloride removal, sulfur removal, and the removal for a multitude of trace metal contaminants. Na2CO3 was found to optimally remove chlorides at an operating temperature of 450ºC. For sulfur removal two regenerable ZnO beds are used for bulk H2S removal at 450ºC (<5 ppm S) and a non-regenerable ZnO bed for H2S polishing at 300ºC (<40 ppb S). It was also found that sulfur from COS could be adsorbed (to levels below our detection limit of 40 ppb) in the presence of water that leads to no detectable slip of H2S. Finally, a sorbent material comprising of Cu and Ni was found to be effective in removing trace metal impurities such as AsH3 and PH3 when operating at 300ºC. Proof-of-concept of the integrated cleanup process was demonstrated with gasifier-generated syngas produced at the Western Research Institute using Wyoming Decker Coal. When operating with a ~1 SLPM feed, multiple inorganic contaminant removal sorbents and a tar-reforming bed was able to remove the vast majority of contaminants from the raw syngas. A tar-reforming catalyst was employed due to the production of tars generated from the gasifier used in this particular study. It is envisioned that in a real application a commercial scale gasifier operating at a higher temperature would produce lesser amount of tar. Continuous operation of a poison-sensitive copper-based WGS catalyst located downstream from the cleanup steps resulted in successful demonstration.

Sorption-enhanced Synthetic Natural Gas (SNG) Production from Syngas: A Novel Process Combining CO Methanation, Water-Gas Shift, and CO2 Capture

The Characteristics of A Sorption-Enhanced Steam-Methane Reaction for the Production of Hydrogen Using Co2 Sorbent

Coal-Derived Warm Syngas Purification and CO<sub>2</sub> Capture-Assisted Methane Production

CO Hydrogenation Combined with Water-Gas-shift Reaction for Synthetic Natural Gas Production: a Thermodynamic and Experimental Study

Methanation of Coke Oven Gas over Ni-Ce/γ-Al2O3 Catalyst Using a Tubular Heat Exchange Reactor: Pilot-scale Test and Process Optimization

Integrated Process for Synthetic Natural Gas Production from Coal and Coke-Oven Gas with High Energy Efficiency and Low Emission

The High Efficient Synthesis of Natural Gas from a Joint-Feedstock of Coke-Oven Gas and Pulverized Coke Via a Chemical Looping Combustion Scheme

Tunable Syngas Production from Biomass: Synergistic Effect of Steam, Ni-CaO Catalyst, and Biochar

Water-saving Dry Methanation for Direct Conversion of Syngas to Synthetic Natural Gas over Robust Ni0.1Mg0.9Al2O4 Catalyst

Synthetic natural gas via integrated high-temperature electrolysis and methanation: Part I—Energy performance

Improving Methane Production Efficiency from Biomass Product Gas Via Pressurized Fluidized Bed System

Thermodynamic Analysis of Integrated Sorption-Enhanced Staged-Gasification of Biomass and In-Situ CO2 Utilization by Methane Reforming Process Based on Calcium Looping

Integrated study on syngas-to-synthetic natural gas (SNG) process

Thermodynamic analyses of synthetic natural gas production via municipal solid waste gasification, high-temperature water electrolysis and methanation

Synthetic Natural Gas Production from CO2 and Renewable H2: Towards Large-Scale Production of Ni–Fe Alloy Catalysts for Commercialization

Dispersed and High Loading Ni Catalyst Stabilized in Porous SiO2 Matrix for Substituted Natural Gas Production

Novel design of in-situ hydrogen sorption/storage integrated enhanced hydrogen production in supercritical CO2 gasification, air gasification, and steam gasification from biomass

Sorption Enhanced Coal Gasification for Hydrogen Production Using A Synthesized Cao-Mgo-Molecular Sieve Sorbent

Gasification for SNG-power cogeneration using coal as material integrated with calcium looping for enhancing CO2 absorption

Metal-foam-structured Ni–Al2O3 Catalysts: Wet Chemical Etching Preparation and Syngas Methanation Performance

Efficient Production of Tunable Syngas Through Multistage Sorption-Enhanced Steam Gasification of Corncob