Abstract:In order to study the mechanism of biomass tar formation and elimination in a two-stage downdraft gasifier, the nascent rice straw pyrolysis tar evolution properties under homogeneous/heterogeneous decomposition conditions have been investigated in a constructed lab-scale two-stage reactor by varying factors as temperature, concentration and reforming agents of CO(2)/H(2)O/O(2), and char bed heights. The nascent tar was produced in the first stage reactor and then decomposed in the second stage with different reforming agents or char beds. In the first stage, the results showed that nascent pyrolysis tar yields increased with increasing pyrolysis temperature, tar was mainly produced during 200-400 degrees C, and 400-500 degrees C would be a proper pyrolysis temperature range in commercial operation due to little effect on tar yields in higher temperature. In the second stage, it can be observed that nascent biomass tar was converted into polycyclic aromatic hydrocarbons (PAHs) (even soot), thermally stable one ring aromatics, and noncondensable gases in homogeneous conditions with increasing temperature. Different effects were obtained in varying tar species under different homogeneous reforming agents. However, benzene, toluene, styrene, phenol, and naphthalene are the most typical compounds, accounting for 50-75% in total tar concentration at 900 degrees C in all decomposition conditions. Char bed can selectively reduce PAH species remarkably and increase the toluene yields. As for the three reforming agents, steam showed the highest efficiency in tar elimination, while CO(2) and O(2) present will induce OH, H, and O radicals formation, which increases hydrocarbon conversion. The mechanism of tar destruction in a two-stage downdraft gasifier can be concluded as follows: nascent tar yields from the pyrolysis stage will be first reformed into PAHs, thermally stable one ring aromatics and noncondensable gases in the throat region, and then PAHs species are almost completely decomposed by the char bed, which are the main troublesome tar components in syngas, and finally the syngas with low tar was obtained.

Evaluating Tar Production Via the Release of Volatile Matters for H2-rich Syngas Production

Utilization of Tar in Biomass Gasification Reburning Process

EFFECT OF GASIFYING MEDIUM ON TAR CONTENT IN HYDROGEN PRODUCTION FROM SAWDUST GASIFICATION PROCESS

Production of Tar during the Process of Biomass Gasification

Experimental Investigation Of Tar Reduction Properties By Coupling Oxidative Pyrolysis And Partial Oxidation In A Continuous Reactor For Biomass Gasification

Simultaneous Tar Reforming and Syngas Methanation for Bio-Substitute Natural Gas

Deoxygenated pyrolysis-gasification of biomass for intensified bio-oil and syngas co-production with tar abatement

Evolving characteristics of tar during biomass fluidized bed gasification

Experimental and Artificial Intelligence Study on Catalytic Reforming of Tar over Bio-Char Surface Coupled with Hydrogen Production

Tar Conversion in Biomass Gasification

Experimental Research on Model Compound Reforming of Biomass Tar to Produce H2-rich Gas

Characteristics of No-Reduction by Tar-Included Syngas from an Updraft Gasifier

From cellulose to tar: Analysis of tar formation pathway with distinguishing the primary and secondary reactions

Characterization Studies of Tar-Containing Wastewater for Bio-Energy and Chemical Production

Generation features and kinetics of gas products in bio-tar catalytic cracking by char for biomass gasification

Effects of Steam and CO2 on Gasification Tar Composition and Evolution of Aromatic Compounds.

Experimental study on hydrogen production from heavy tar in biomass gasification furnace catalyzed by carbon-based catalysts

Experimental Investigation on Tar Formation and Destruction in A Lab-Scale Two-Stage Reactor

Nascent Biomass Tar Evolution Properties under Homogeneous/Heterogeneous Decomposition Conditions in a Two-Stage Reactor

Syngas Production at Low Temperature Via the Combination of Hydrothermal Pretreatment and Activated Carbon Catalyst along with Value-Added Utilization of Tar and Bio-Char

Experimental and numerical investigation of tar destruction under partial oxidation environment