Abstract:An experimental study on NO reduction by biomass gasification tar had been carried out on the flow reaction system. Tar is so complex that tar model compounds were selected to reduce NO. Those model compounds were benzene, toluene, styrene, and phenol. According to the thermogravimetry−mass spectrometry (TG−MS) analyses of pyrolysis and gasification of rice straw, corn stalk, and corncob, these four compounds are main compositions of biogas tar. Experimental results show that the four model compounds have different effects on NO reduction, and we study their NO reduction effect individually in this paper to shed light on the reburning effect of the main species of tar. NO reduction efficiency, η, is obtained from fuel-lean to fuel-rich conditions of each fuel in the temperature range of 900−1400 °C. In general, phenol leads to a better performance under the experiment conditions, and NO reduction efficiency is maintained at almost 30−40% and changes little with temperature. For benzene, NO reduction efficiency is correspondingly low under the temperature ranges. Toluene and styrene, which have a hydrocarbon substituent attached to the benzene ring, perform better than benzene. The NO reduction efficiency of toluene is low at lower temperatures but increases a lot with increasing temperature, and the fuel-rich condition is helpful for reducing NO. NO reduction efficiency of styrene increases a little with temperature and changes a lot with the bulk equivalence ratio under higher temperatures (1100−1400 °C), but the maximum efficiency occurred at almost the same bulk equivalence ratio, φ = 1.27. For benzene and phenol, fuel-lean conditions favor their performance. The results will instruct further research and engineering application of biogas reburning.

Characteristics of No-Reduction by Tar-Included Syngas from an Updraft Gasifier

Experimental Study on NO Reduction by Reburning of Biomass Gasification Syngas with Tar

Experimental and Kinetic Study of NOx Reduction by Reburning Using Syngas from Updraft Biomass Gasification with Phenol As a Model Compound for Tar

Effect of Tar on NO Reduction by Biomass Gasification Syngas Reburning

Experimental and kinetic study of the NO-reduction by tar formed from biomass gasification, using benzene as a tar model component

Utilization of Tar in Biomass Gasification Reburning Process

Effect of Biomass Gasification Tar on NO Reduction by Biogas Reburning

Experimental Study on the Effect of NO Reduction by Tar Model Compounds

Evaluating Tar Production Via the Release of Volatile Matters for H2-rich Syngas Production

Thermodynamic and kinetic study of NO reduction by pyridine/pyrrole during biomass tar reburning: the quantum chemical method approach

Experimental Study of Soot Inception by Biomass Gasification Tar

Experimental Investigation Of Tar Reduction Properties By Coupling Oxidative Pyrolysis And Partial Oxidation In A Continuous Reactor For Biomass Gasification

Simultaneous Tar Reforming and Syngas Methanation for Bio-Substitute Natural Gas

Upgraded Syngas Through Selective Partial Oxidation of Tar Using Ni-doped LaFeO3 with Tuned Oxidation Potential

Numerical Simulation of NO Reduction by Gases from Coal Pyrolysis at High Temperature

Catalytic Conversion of Tar from Hot Coke Oven Gas Using 1-Methylnaphthalene As a Tar Model Compound

Effective Syngas Cleanup and Reforming Using Ni

Heterogeneous Cracking Reaction of Tar over Biomass Char, Using Naphthalene As Model Biomass Tar

Experimental and numerical investigation of tar destruction under partial oxidation environment

Experimental Investigation of Tar Conversion under Inert and Partial Oxidation Conditions in a Continuous Reactor