Abstract:The study investigated the effects of pre-treated olivine in dual bed steam gasification (DBSG) of biomass compost in order to produce H-2 enriched synthesis gas with significantly reduced tar formation. The DBSG employed circulating fluidized bed (CFB) of silica sand as first stage and fixed catalytic bed of pre-treated olivine as second stage. The mixed biomass compost contained 15-20 wt. % of agri-residues (mainly wheat straw) and 80-85 wt. % of cow manure. The study compared the synthesis gas distribution and tar reductions using pre-treated olivine in the DBSG scheme with Ni-Al based DBSG scheme. The effects of operating condition on the synthesis gas distribution and tar formation are studied such as: (i) effect of steam to biomass ratio, (ii) effects of relative oxidation (relox), (iii) operating temperature of the reactor, (iv) performance and comparison of employed catalysts, and (v) yield of synthesis gas together with carbon conversion efficiency. Experimental analysis showed that H-2 concentration obtained from pre-treated olivine based DBSG is considerably higher than H-2 produced from compared gasification schemes. The H-2 production is favoured at higher temperatures and higher SBR under the influence of pre-treated olivine catalyst. However, the conditions are less advantageous for the production of CO and CH4. Among all experiments, the synthesis gas composition obtained at SBR = 1.40 and at 800 degrees C consisted of highest H-2 concentration (35 vol.% d.n.f) in the pre-treated olivine DBSG. Higher steam to biomass ratio (SBR) resulted in lower cold gas energy efficiency and lower heating value of the synthesis gas mainly due to large steam content in the gas. The tar removal efficiency of 98% is achieved with the pre-treated olivine DBSG system. The total tar content is significantly reduced (approximate to 40%) in the DBSG with pre-treated olivine. Higher relative oxidation resulted in increased concentration of CO2 in the synthesis gas due to increased partial oxidation of organic matter in the gasifier. The pre-treated olivine catalyst in the DBSG consistently promoted the process of steam reforming and tar cracking and thus improved the quality of the syngas by limiting the tar contents. (C) 2016 Hydrogen Energy Publications LLC. Published by Elsevier Ltd. All rights reserved.

EFFECT OF GASIFYING MEDIUM ON TAR CONTENT IN HYDROGEN PRODUCTION FROM SAWDUST GASIFICATION PROCESS

Evaluating Tar Production Via the Release of Volatile Matters for H2-rich Syngas Production

Hydrogen Production from Catalytic Steam Reforming of Benzene As Tar Model Compound of Biomass Gasification

Experimental Research on Model Compound Reforming of Biomass Tar to Produce H2-rich Gas

Experimental Investigation of Biomass Gasification in a Fluidized Bed Reactor

Experimental Investigation Of Tar Reduction Properties By Coupling Oxidative Pyrolysis And Partial Oxidation In A Continuous Reactor For Biomass Gasification

Steam Gasification of Biomass for Hydrogen-Rich Gas in a Free-Fall Reactor

Hydrogen and Syngas Production from Steam Gasification of Biomass Using Cement As Catalyst

Biomass Steam Gasification for Hydrogen-Rich Gas Production in a Decoupled Dual Loop Gasification System

An Experimental Study on Hydrogen Enriched Gas with Reduced Tar Formation Using Pre-Treated Olivine in Dual Bed Steam Gasification of Mixed Biomass Compost

Synergistic effect of hydrogen atmosphere and biochar catalyst on tar decomposition and methane-rich gas production during biomass pyrolysis

Hydrogen-rich gas production from biomass steam gasification in an updraft fixed-bed gasifier combined with a porous ceramic reformer

Adjustment of Biomass Product Gas to Raise H2/CO Ratio and Remove Tar over Sodium Titanate Catalysts

Hydrogen Production by Biomass Gasification at Low Temperature and Catalytic Reforming of the Volatile

Evolving characteristics of tar during biomass fluidized bed gasification

Optimization of Operating Parameters for Tar Reforming/hydrogen Upgrading in Corn Straw Pyrolysis Polygeneration

Effects of Steam and CO2 on Gasification Tar Composition and Evolution of Aromatic Compounds.

Experimental Study on Influence of Operating Parameters on Tar Components from Corn Straw Gasification in Fluidized Bed

Effect of Steam on the Tar Reforming during Circulating Fluidized Bed Char Gasification

Utilization of Tar in Biomass Gasification Reburning Process

Parametric effect of biomass partial hydropyrolysis process in a downer reactor to co-produce high-quality tar and syngas