Abstract:By collecting the ripple current in the control coil, the self-sensing magnetic bearings can obtain rotor displacement information without a displacement sensor, which has the advantages of low cost and high integration. According to the problems of incomplete and inaccurate displacement information extraction caused by the traditional displacement estimation method using Fourier method to analyze the ripple current with non-stationary characteristics to estimate the rotor displacement with the Gibbs effect. Therefore, this paper proposes a rotor displacement estimation algorithm based on multiresolution filter bank biorthogonal spline wavelet for a magnetic bearing motor based on two-level switching power amplifier. This algorithm utilizes the biorthogonal spline wavelet with the characteristics of generalized linear phase and tight support, which can accurately demodulate the ripple current in the coil and extract the displacement information in the ripple current. Therefore, it is able to overcome the Gibbs effect in the traditional Fourier analysis estimation algorithm, to reduce the influence of ripple on rotor displacement estimation, and to improve the accuracy and stability of displacement estimation. In order to verify the correctness and effectiveness of the proposed algorithm, this paper establishes a simulation model of magnetic bearing in MATLAB Simulink and designs the proposed displacement estimator. Simulation results demonstrate that the proposed algorithm has higher accuracy and better stability than traditional displacement estimation algorithms. Experimental results show that the maximum deviation rate of the displacement estimation method proposed in this paper does not exceed 1% when the radial magnetic bearing gap is 0.5 mm, which can effectively estimate the rotor displacement.

A Rotor Displacement Estimation Method for Magnetic Bearings with Direct Measurement of the Ripple Current Slope

Rotor Position Estimation Strategy for Self-Sensing Active Magnetic Bearing Considering Eddy Currents

Self-sensing Active Magnetic Bearing Using Real-Time Duty Cycle

Self-sensing active magnetic bearing using Hilbert transform

Displacement Estimation of Self-Sensing Magnetic Bearings Based on Biorthogonal Spline Wavelet

An Improved Method to Estimate Initial Rotor Position for Surface-Mounted Permanent Magnet Synchronous Motors

Position Estimation Accuracy Improvement Based on Accurate Modeling of Self-Sensing Active Magnetic Bearings

Self-sensing active magnetic bearing using wavelet based position estimation algorithm

The Precise Modeling and Analysis of Demodulation Approach in Self-sensing Active Magnetic Bearings

An improved rotor position estimation in PMSM with low-resolution hall-effect sensors

Cooperative Rotor Position Estimation of Active Magnetic Bearings with Unsaturated Magnetic Bias

Self-Sensing Of The Rotor Position And Displacement For An Inset Permanent Magnet Type Bearingless Motor

An Improved Rotor Position Estimation Method for PMSM Using Low-Resolution Hall-Effect Sensors

A Multifrequency Disturbances Identification and Suppression Method for the Self-Sensing AMB Rotor System

Rotor Displacement Sensorless Control Strategy for PM Type Bearingless Motor Based on the Parameter Identification

Rotor Position Estimation for Aviation Three-Stage Starter/Generators in the Low-Speed Region Without High-Frequency Signal Injection

Position and radial displacement sensorless control method for bearingless switched reluctance motors

Unbalance Compensation by Recursive Seeking Unbalance Mass Position in Active Magnetic Bearing-Rotor System

A recurrent neural network‐based rotor displacement estimation method for eight‐pole active magnetic bearing

A Novel Initial Rotor Position Estimation Method for Permanent Magnet Synchronous Motors

Study on Inverter-fed Three-pole Active Magnetic Bearing