Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Experimental Investigation on Flow Condensation Heat Transfer and Pressure Drop of Nitrogen in Horizontal Tubes

Experiment and Simulation on Downward Flow Condensation of Nitrogen in Vertical Tubes

An Experiment-Based Comparative Investigation of Correlations for Microtube Gas Flow

Experimental Study on Saturated Flow Boiling Heat Transfer of Nitrogen in a Small-Diameter Horizontal Heated Tube

Single-phase pressure drop and heat transfer characteristics of turbulent liquid nitrogen flow in micro-tubes

Experimental Study on the Heat Transfer Characteristics of Saturated Liquid Nitrogen Flow Boiling in Small-Diameter Horizontal Tubes

EXPERIMENTAL STUDY ON THE SINGLE-PHASE FLOW AND HEAT TRANSFER OF LIQUID NITROGEN IN MICRO-TUBES

Two-phase Flow Boiling Frictional Pressure Drop of Liquid Nitrogen in Horizontal Circular Mini-Tubes: Experimental Investigation and Comparison with Correlations

Study on High-Speed Condensation Heat Transfer of Steam/nitrogen Mixture in Horizontal Rectangular Channel

Influence of Operating Conditions on In-Tube Vapour Condensation Heat Transfer Characteristics in the Presence of Noncondensable Gases at High Pressure

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Experimental Study on Heat Transfer Characteristics of LN2 Saturated Flow Boiling in a Horizontal Corrugated Tube

Forced Condensation Heat Transfer Characteristics of Vapour in the Presence of Noncondensable Gas in Horizontal Tubes Operating at High Pressures

Theoretical and Experimental Analyses of Two-Phase Flow Condensation Heat Transfer Inside the Horizontal Micro-Fin Tube

Flow boiling of liquid nitrogen in micro-tubes: Part II – Heat transfer characteristics and critical heat flux

Experimental Investigation on Heat Transfer Characteristics of Supercritical Nitrogen in a Heated Vertical Tube

Experimental Study on Condensation of Steam/air Mixture in a Horizontal Tube

Two-phase Pressure Drop of Ammonia in Horizontal Small Diameter Tubes: Experiments and Correlation

Flow boiling of liquid nitrogen in a horizontal macro-tube at low pressure: Part II – Heat transfer characteristics

Convective heat transfer coefficients for near-horizontal two-phase flow of nitrogen and hydrogen at low mass and heat flux

Flow Boiling of Liquid Nitrogen in Micro-Tubes：two-phase Flow Pressure Drop