Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Convective heat transfer coefficients for near-horizontal two-phase flow of nitrogen and hydrogen at low mass and heat flux

Experimental Investigation on Flow Condensation Heat Transfer and Pressure Drop of Nitrogen in Horizontal Tubes

Single-phase pressure drop and heat transfer characteristics of turbulent liquid nitrogen flow in micro-tubes

Experimental Study on the Heat Transfer Characteristics of Saturated Liquid Nitrogen Flow Boiling in Small-Diameter Horizontal Tubes

Convective Heat Transfer Coefficient for a Rod-Like Particle in a Uniform Flow

Friction Factor and Nusselt Number Correlations for Forced Convection in Helical Tubes

Experimental Study on Saturated Flow Boiling Heat Transfer of Nitrogen in a Small-Diameter Horizontal Heated Tube

A Numerical Study of Supercritical Forced Convective Heat Transfer of N-Heptane Inside A Horizontal Miniature Tube

Flow boiling of liquid nitrogen in a horizontal macro-tube at low pressure: Part II – Heat transfer characteristics

Nusselt Number Correlation for Turbulent Heat Transfer of Helium–xenon Gas Mixtures

Flow boiling of liquid nitrogen in micro-tubes: Part II – Heat transfer characteristics and critical heat flux

Numerical Investigation of Convective Heat Transfer to Supercritical Pressure Hydrogen in a Straight Tube

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Experimental Study on Heat Transfer Characteristics of LN2 Saturated Flow Boiling in a Horizontal Corrugated Tube

EXPERIMENTAL STUDY ON THE SINGLE-PHASE FLOW AND HEAT TRANSFER OF LIQUID NITROGEN IN MICRO-TUBES

Heat Transfer Enhancement of Supercritical Nitrogen Flowing Downward in a Small Vertical Tube: Evaluation of System Parameter Effects

Experimental Investigation on Flow and Heat Transfer Characteristics of Helium in Rectangular Narrow Slit Channel

Heat Transfer of Hydrogen with Variable Properties in a Heated Tube

Assessment of existing two phase heat transfer coefficient and critical heat flux correlations for cryogenic flow boiling in pipe quenching experiments

Investigation on Laminar Flow and Heat Transfer of Helium–Xenon Gas Mixtures with Variable Properties

FLOW BOILING OF LIQUID NITROGEN IN MICRO-TUBE——TWO-PHASE HEAT TRANSFER ANALYSIS