Abstract:This paper presents a numerical model to study the process of vapor condensation on surfaces characterized by film-wise condensation with the presence of Non-condensable gases (NCG). State variables in both the condensate film and the diffusion layer were solved separately and the condensation interface was used to couple the two solutions. The solution of the condensate film was obtained using well-established solutions of laminar film condensation of pure vapor. In contrast to other models surveyed, this work provides a inexpensive and accurate predictions of heat and mass transfer characteristics. We validated the work against two classical condensation problems. The model was first validated against empirical correlations and experimental work, resulting in a very good agreement. We then assessed the applicability of ignoring the condensate film effect, as performed in previous models, on the condensation processes by observing the thermal resistances of both the condensate film and diffusion layer. Results indicated that for the studied cases of NCG mass fractions above 20%, the condensate thermal resistance was at least an order of magnitude lower than that of the diffusion layer. However, the two thermal resistances seem to approach each other as NCG mass fraction becomes smaller. On another front, we observed that models that ignore the condensate film thermal resistance underestimate the interfacial temperature albeit accurately predicting the overall heat transfer rate. To simulate even lower NCG mass fractions, we validated our model to the classical analytical work of Sparrow and co-workers. Results showed a striking agreement between the two solutions at different NCG mass fractions (0.5%–10%) and subcooling degrees (5∘F–40∘F). Finally, we found a good agreement between results of our model and the heat/mass transfer analogy. The heat/mass transfer analogy is a semi-empirical method therefore, is limited to the existing correlations and their uncertainties. On the other hand, our model does not use any empiricism and relies on the available solutions of laminar condensate film of pure vapor in predicting the liquid side heat transfer coefficient.

Numerical Analysis of Nitrogen Condensation Heat Transfer Enhancement with Liquid Film Fluctuation at Cryogenic Temperature

Characteristic Analysis of Fluctuating Liquid Film Flow Behavior and Heat Transfer in Nitrogen Condensation

Experiments and numerical simulation of dynamic cool-down process of stainless steel plate in liquid nitrogen bath

Observation and Analysis of the Detachment Frequency of Coalesced Bubbles in Pool Boiling Liquid Nitrogen

Numerical Analysis of Heat Transfer Characteristics of a Falling Film Type Plate-Fin Condenser/Reboiler

Experimental Study on Film Condensation Characteristics at Liquid Nitrogen Temperatures

Visualization Experiment and Numerical Simulation of Nitrogen-Neon Mixture Condensation

Enhancing Heat Transfer Performance of Nitrogen Condensation on Vertical Plate with Microstructure

Numerical Study of Condensation Heat Transfer Performance and Liquid Film Distribution Characteristics in Small-Scale Helium Liquefiers

Numerical Simulation of Nitrogen Vapor Condensation on Microstructure Surface

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Numerical Study of Conjugate Heat Transfer of Cryogenic Methane in Rectangular Engine Cooling Channels at Supercritical Pressures

Experimental Study on the Condensation Characteristics of Nitrogen with Non-Condensable Gas

Numerical modeling of vapor condensation over a wide range of non-condensable gas concentrations

Numerical investigation on the impact of injection rates on cooling performance in a rotor-stator cavity with liquid nitrogen spraying

Numerical Analysis of Cryogenic LOX-LN2 Mass Transfer Characteristics under Different Textured Surfaces

Study on Convective Heat Transfer of Supercritical Nitrogen in a Vertical Tube for Liquid Air Energy Storage

On the Unsteady Cavitation Characteristics of Compressible Liquid Nitrogen Flows Through a Venturi Tube

Numerical Study of the Forced Convective Condensation on a Short Vertical Plate

Experimental Study of Cryogenic Oxygen–nitrogen Mass Transfer Characteristics on Microtextured Plates

Influence of Structured Packing Geometric Parameters on Flow and Mass Transfer Performance of Liquid Nitrogen and Oxygen for Cryogenic Distillation