Abstract:This paper presents a numerical model to study the process of vapor condensation on surfaces characterized by film-wise condensation with the presence of Non-condensable gases (NCG). State variables in both the condensate film and the diffusion layer were solved separately and the condensation interface was used to couple the two solutions. The solution of the condensate film was obtained using well-established solutions of laminar film condensation of pure vapor. In contrast to other models surveyed, this work provides a inexpensive and accurate predictions of heat and mass transfer characteristics. We validated the work against two classical condensation problems. The model was first validated against empirical correlations and experimental work, resulting in a very good agreement. We then assessed the applicability of ignoring the condensate film effect, as performed in previous models, on the condensation processes by observing the thermal resistances of both the condensate film and diffusion layer. Results indicated that for the studied cases of NCG mass fractions above 20%, the condensate thermal resistance was at least an order of magnitude lower than that of the diffusion layer. However, the two thermal resistances seem to approach each other as NCG mass fraction becomes smaller. On another front, we observed that models that ignore the condensate film thermal resistance underestimate the interfacial temperature albeit accurately predicting the overall heat transfer rate. To simulate even lower NCG mass fractions, we validated our model to the classical analytical work of Sparrow and co-workers. Results showed a striking agreement between the two solutions at different NCG mass fractions (0.5%–10%) and subcooling degrees (5∘F–40∘F). Finally, we found a good agreement between results of our model and the heat/mass transfer analogy. The heat/mass transfer analogy is a semi-empirical method therefore, is limited to the existing correlations and their uncertainties. On the other hand, our model does not use any empiricism and relies on the available solutions of laminar condensate film of pure vapor in predicting the liquid side heat transfer coefficient.

Visualization Experiment and Numerical Simulation of Nitrogen-Neon Mixture Condensation

CFD Simulations and Experimental Verification on Nucleate Pool Boiling of Liquid Nitrogen

Numerical Analysis of Nitrogen Condensation Heat Transfer Enhancement with Liquid Film Fluctuation at Cryogenic Temperature

Characteristic Analysis of Fluctuating Liquid Film Flow Behavior and Heat Transfer in Nitrogen Condensation

Experimental Study on Film Condensation Characteristics at Liquid Nitrogen Temperatures

Experimental Study on the Condensation Characteristics of Nitrogen with Non-Condensable Gas

Visualization experimental study on NO2 condensation process: Insights into gas-fog-liquid-ice mode evolution

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube

Numerical modeling of vapor condensation over a wide range of non-condensable gas concentrations

Numerical Simulation of Nitrogen Vapor Condensation on Microstructure Surface

On the Unsteady Cavitation Characteristics of Compressible Liquid Nitrogen Flows Through a Venturi Tube

Effects of Liquid Film Waviness, Suction, and Fog Formation on Condensation in the Presence of Noncondensable Gases

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Condensation heat and mass transfer of steam with non-condensable gases outside a horizontal tube under free convection

Numerical simulation of condensation from isobutane vapour – air mixture

Numerical simulation on the effect of non-condensable gas on direct contact condensation of steam jet in a narrow pipe

Visualization study of the influence of non-condensable gas on steam condensation heat transfer

Numerical Simulations of Laminar Film Condensation of H2O/Air or H2O/CO2 on a Vertical Plate

Theoretical Modeling of Vapor Condensation in the Presence of Noncondensable Gas on a Horizontal Tube

A condensation heat transfer model with light gas effects in non-condensable gas mixtures

Numerical Simulation of the Heat and Mass Transfer Process of Convective Condensation With Non-Condensable Gas