Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Numerical Simulation of the Heat and Mass Transfer Process of Convective Condensation With Non-Condensable Gas

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube

Numerical simulation on the effect of non-condensable gas on direct contact condensation of steam jet in a narrow pipe

Condensation heat and mass transfer of steam with non-condensable gases outside a horizontal tube under free convection

Effect of Non-Condensable Gases on Steam Condensation in a Vertical Pipe with Forced Convection

CFD simulation of water vapour condensation in the presence of non-condensable gas in vertical cylindrical condensers

THE EXPERIMENTAL INVESTIGATION OF STEAM CONDENSATION WITH NON-CONDENSABLE GAS UNDER NATURAL CONVECTION

Effect of Non-Condensation Gas on Heat Transfer of Direct Contact Condensation

Condensation of vapor in the presence of non-condensable gas in condensers

Numerical Investigation of Air-Steam Condensation in a Vertically Enhanced Tube with Concave and Convex Surfaces

Numerical investigation on submerged steam jet condensation in subcooled water flow in a restricted channel with the presence of non-condensable gas

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Numerical simulation study on heat transfer characteristics of steam condensation in the presence of multi-component non-condensable gas outside the tube bundle

A numerical study on convective condensation of flue gas in tubular heat exchangers

Research on Convective Condensation Heat Transfer for a Gas Mixture in a Vertical Tube

Numerical Investigation of Natural Convective Condensation with Noncondensable Gases in the Reactor Containment after Severe Accidents

Theoretical Modeling of Vapor Condensation in the Presence of Noncondensable Gas on a Horizontal Tube

The Investigation on Heat Transfer Characteristics of Steam Condensation in Presence of Noncondensable Gas under Natural Convection

Numerical Simulations of Laminar Film Condensation of H2O/Air or H2O/CO2 on a Vertical Plate

Research on fluid flow and heat transfer characteristics in a three-dimensional condenser

Theoretical and Experimental Analyses of Two-Phase Flow Condensation Heat Transfer Inside the Horizontal Micro-Fin Tube