Abstract:Although defect engineering is the core strategy to improve thermoelectric properties, there are limited methods to effectively modulate the designed defects. Herein, we demonstrate that a high ZT value of 1.36 at 775 K and a high average ZT value of 0.99 in the temperature range from 300 to 825 K are realized in Zn-containing PbTe by designing complex defects. By combining first-principles calculations and experiments, we show that Zn atoms occupy both Pb sites and interstitial sites in PbTe and couple with each other. The contraction stress induced via substitutional Zn on Pb sites alleviates the swelling stress by Zn atoms occupying the interstitial sites and promotes the solubility of interstitial Zn atoms in the structure of PbTe. The stabilization of Zn impurity as a complex defect extends the region of PbTe phase stability toward Pb0.995Zn0.02Te, while the solid solution region in the other direction of the ternary phase diagram is much smaller. The evolution of defects in PbTe was further explicitly corroborated by aberration-corrected scanning transmission electron microscopy (Cs-corrected STEM) and positron annihilation measurement. The Zn atoms compensate the Pb vacancies (VPb) and Zn interstitials (Zni) significantly improve the electron concentration, producing a high carrier mobility of 1467.7 cm2 V–1 s–1 for the Pb0.995Zn0.02Te sample. A high power factor of 4.11 mW m–1 K–2 is achieved for the Pb0.995Zn0.02Te sample at 306 K. This work provides new insights into understanding the nature and evolution of the defects in n-type PbTe as well as improving the electronic and thermal transport properties toward higher thermoelectric performance.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acsami.1c14518.Experimental section, backscattering electron images, wavelength dispersive spectrometer results, electrical and thermal transport performance of the Pb1–yZnyTe samples, and room-temperature carrier mobility as a function of carrier concentration for the Pb1–yZn0.015+yTe samples and several n-type PbTe compounds (PDF)This article has not yet been cited by other publications.

Defect Modulation on CaZn1-xAg1-ySb (0 < X < 1; 0 < Y < 1) Zintl Phases and Enhanced Thermoelectric Properties with High Zt Plateaus

Defect Chemistry, Phase Transitions, and Thermoelectric Properties of Ca1–xCexAg1–ySb (0 ≤ X ≤ 1; 0 ≤ Y ≤ 1)

Point defect approach to enhance the thermoelectric performance of Zintl-phase BaAgSb

Enhanced Thermoelectric Performance of Zintl Phase Ca9Zn4+ xSb9 by Beneficial Disorder on the Selective Cationic Site

Enhancing thermoelectric performance of AB 2 Sb 2 -type Zintl phase through band shaping and lattice distortion

Enhanced Thermoelectric Performance of LiZnSb-Alloyed CaZn 0.4 Ag 0.2 Sb by Band Engineering

Zn-Induced Defect Complexity for the High Thermoelectric Performance of n-Type PbTe Compounds

Achieving n-type Conduction in AMg2Sb2 (A = Yb, Eu, Ca, Sr, Ba) Zintl Phases

Planar Zintl-phase high-temperature thermoelectric materials XCuSb (X = Ca, Sr, Ba) with low lattice thermal conductivity

Realizing high thermoelectric performance in p-type CaZn2Sb2-alloyed Mg3Sb2-based materials via band and point defect engineering

Tuning the Thermoelectric Properties of Ca9zn4+Xsb9 by Controlled Doping on the Interstitial Structure

Promising Zintl-Phase Thermoelectric Compound SrAgSb

Zintl-phase Eu2ZnSb2: A promising thermoelectric material with ultralow thermal conductivity

High Thermoelectric Performance in Cu2SnS3 by Control Over Phase‐Dependent Mobility Edge

Improved Thermoelectric Performance in the Zintl Phase Compounds YbZn2−xMnxSb2 Via Isoelectronic Substitution in the Anionic Framework

In-Plane Overdamping and Out-Plane Localized Vibration Contribute to Ultralow Lattice Thermal Conductivity of Zintl Phase KCdSb

Point Defect Engineering of High‐Performance Bismuth‐Telluride‐Based Thermoelectric Materials

Vacancies tailoring lattice anharmonicity of Zintl-type thermoelectrics

Band Modification Towards High Thermoelectric Performance of SnSb2Te4 with Strong Anharmonicity Driven by Cation Disorder

Defect Control In Ca1-Delta Ce Delta Ag1-Delta Sb(Delta Approximate To 0.15) Through Nb Doping

Exceptional thermoelectric performance in AB 2 Sb 2 -type Zintl phases through band shaping