Abstract:The co-processing of hazardous waste in cement kiln can eliminate a large number of hazardous wastes, but the excessive existence of chlorine will affect normal operation of cement kiln. In this study, the partition of Cl in flue gas, fly ash and residual solid under different experiment conditions was obtained by using tubular furnace to incinerate mixtures of rectification residue and raw meal. The chlorine content in flue gas was determined using ion chromatography and the chlorine content in fly ash and residual solid was measured by high temperature combustion hydrolyzing-ion chromatography. The results showed that chlorine mainly existed in flue gas and residual solid, and only less than 3.5% of chlorine existed in fly ash. The incineration temperature had a significant effect on the distribution of chlorine in each part. The higher the incinerating temperature, the greater the proportion of chlorine in flue gas and fly ash. While temperatures were higher than 1300 degrees C, the proportion of chlorine in all parts remained basically unchanged, roughly 18:14:1. With the increase of the retention time, the proportion of chlorine in the residual solid decreased gradually, and the proportion of chlorine in the flue gas increased gradually. The distribution ratio of chlorine in each part remained unchanged after about 30 min. In addition, the chlorine content of the sample and the air flow rate had a relatively slight effect on the partition of chlorine. Based on these experimental results, some suggestions on the co-processing of hazardous waste in cement kiln were put forward. (C) 2018 Elsevier Ltd. All rights reserved.

HCl EMISSION DURING CHLORIDE WASTES COMBUSTION PROCESS

[Experimental and Mechanism Analyses on HCl Emission Control During PVC Combustion in Fixed Beds].

Review on the Emission and Dechlorination of HCl in Combustion of MSW

INDUSTRIAL EXPERIMENT STUDY ON CHLORID EMISSION AND DECHLORINATION TECHNOLOGY

Migration and Agglomeration of Chlorine in Dechlorination of Coal-Fired Flue Gas

B202 In-furnace Reduction of HCI Emission by Alkali-based Sorbents During PVC Combustion in Fixed Bed

Experimental Study of HCl Emissions and Removal During Combustion of Coal Mixed and Diluted with Sewage Sludge

Experimental Study of Emission of HCl on Incinerating of Typical Municipal Solid Waste Components

Experimental Study on HC1 Real-time Emission Characteristics in Simulated Municipal Solid Waste Incineration

Experimental Research on Emission and Capture of HCl in MSW Incineration

Dichlorination in a Circulating Fluidized-Bed Incinerator for Municipal Solid Waste Incineration System

Effect of n(Na+)/n(Cl-) on Semi-dry Dechlorination in Coal-fired Flue Gas to Realize Zero Emission of FGD Waste Water

Study on the Evolution and Transformation of Cl During Co-incineration of a Mixture of Rectification Residue and Raw Meal of a Cement Kiln.

Experiments of PVC Gasification in a Fluidized Bed

Experimental Study of HCl Emission and Removal on Incinerating of Typical MSW Components in Fluidized Bed

HCl and PCDD/Fs emission characteristics from incineration of source-classified combustible solid waste in fluidized bed

Behavior and Control of Chlorine in Dyestuff Residue Incineration

Study on the Evolution and Transformation of Chlorine During Co-Processing of Hazardous Waste Incineration Residue in a Cement Kiln

Effect of additives and steam on chlorine transformation during plasma melting of fly ash

Review on fate of chlorine during thermal processing of solid wastes

Release of Hydrogen Chloride from Combustibles in Municipal Solid Waste.