Abstract:A large-scale supercritical circulating fluidized bed (SCCFB) boiler, which generates steam with supercritical pressure and high temperature, overcomes the major shortcoming of the ambient circulating fluidized bed (ACFB) boiler whose thermal efficiency is not sufficient high, and inherits ACFB's advantage in environmental protection. Its investment and operation cost for desulphurization and low NOX emission guaranteed is less than that of pulverized coal fired (PC) boiler equipped with flue gas desulphurization (FGD) and selected catalytic reaction (SCR). Thus SCCFB is regarded as the next generation clean coal technology.Supported by Chinese Ministry of Science and Technology (MOST), the pre-feasibility study of an 800MWe SCCFB boiler was conducted. The designed fuel was high sulfur bituminous coal. Based on the experience of supercritical pressure PC boiler, once reheat and sliding pressure were adopted, with 604 degrees C and 26.17MPa for fresh steam and 604 degrees C for reheat steam. The boiler was of single furnace with pant legs, and the membrane water walls were composed of once-through vertical smooth tubes with throttle but intermediate mixing. It is found that the thickness of 8mm was safe to prevent the tubes From erosion at various load conditions because of the rather high mass flow rates. The combustion system consisted of 6 thermal-insulated cyclones. 6 water-cooled mechanical distribution valves and 6 external heat exchangers (EHEs). An internal start-tip system with recirlculating pumps was also suggested. The boiler efficiency was about 93% at B-MCR, and emissions of NOX and CO are kept lower than 200mg/Nm(3) and 100mg/Nm(3), respectively. Hydrodynamics performance and material balance at full and partial loads were predicted with a mathematical model. The simulation results confirm the correctness of the design with vertical water wall of the furnace.

Start-up and Hold-down Performance of a CFB Boiler with Water Cooled Square Cyclone

Performance Evaluation of a 220t/h CFB Boiler with Water-Cooled Square Cyclones

Optimization of Start-up Process in Combined Cycle Steam Turbine of a Power Plant

DESIGN AND OPERATION EXPERIENCE OF THE FIRST PILOT 220t/h CIRCULATING FLUIDIZED BED BOILER WITH A WATER COOLED SQUARE CYCLONE

Operation Experience of a 116MW Circulating Fluidized Bed Hot Water Boiler with Water Cooled Square Cyclone

The Update Progress Of Compact Design Cfb Boiler With Square Cyclone

Particle Holdup And Average Residence Time In The Cyclone Of A Cfb Boiler

Restart-up Performance of a CFB Boiler after a Sudden Power Failure Accident

Particle holdup and average residence time in the cyclone of a circulating fluidized bed boiler

Hot test of material balance in a 75 t/h CFB boiler with water cooled square separator

The Progress of the Water Cooled Separator CFB Boiler in China

Performance of a 220 T/h Circulating Fluidized Bed Boiler with Water Cooled Square Shaped Separator

Design of 220t/h Water Cooled Abnormal Cyclone CFB Boiler

Study on the dynamic balance behaviors of bed material during the start-up process of a circulating fluidized bed boiler

Operational Performance and Optimization of A 465t/h Cfb Boiler in China

Conceptual design of a simplified 660 MW ultra-supercritical circulating fluidized bed boiler

Design and Development of a 660 MW High Efficiency Ultrasupercritical Double-furnace CFB Boiler

Dynamic characteristics of pollutant emissions from CFB boilers during periodic fire banking and start-up

Conceptual Design Of An 800mwe Supercritical Pressure Circulating Fluidized Bed Boiler And Its Performance Prediction

Experimental Investigation on a 0.35 MWth Coal-Fired Horizontal Circulating Fluidized Bed Boiler

A study of operation performance of circulating fluidized bed combustion boiler