Abstract:Ethanol dehydration is effectively catalyzed by strongly acidic zeolite catalysts which are known, however, to exhibit poor time on stream stability. Alumina and silica-alumina on the other hand are relatively stable but reach only low activity levels. Here, a series of aluminosilicate catalysts (Si:Al ratio = 16) was prepared by non-hydrolytic sol-gel (NHSG) and are shown to feature an intermediate level of activity, between the HZSM-5 zeolite and a commercial silica-alumina. Importantly, the best samples, were very stable with time on stream. Unlike HZSM-5, which also catalyzes ethylene oligomerization due to its strong acid sites and is therefore prone to coking, NHSG prepared catalysts did not produce any traces of ethylene oligomers and did not show any trace of coke formation. Characterization (ICP-OES, N 2 physisorption, TEM, XPS, IR coupled with pyridine adsorption, Raman spectroscopy, solid state NMR spectroscopy) reveal that the unconventional synthetic method presented here allowed to prepare mesoporous aluminosilicate materials with a remarkable degree of homogeneity. It is this thorough dispersion of Al in the amorphous silicate matrix which is responsible for the formation of acid sites which are intermediate (in terms of strength and nature) between those of commercial silica-alumina and HZSM-5 zeolite. The texture of the best NHSG catalyst – mainly mesoporous with a high specific surface area (800 m2 g −1 ) and pore volume (0.5 cm3 g −1 ) – was also unaffected after reaction. To overcome deactivation issues in ethanol dehydration, this study suggests to target amorphous aluminosilicate catalysts with open mesoporosity and with an intimate mixing of Al and Si.

Effects of Liquid Si-deposition Treatment on Structure and Reaction Stability of Catalyst for Ethanol Dehydration Producing Ethylene

Characteristics of Coke Deposition over A Sapo-34 Catalyst in the Methanol-To-Olefins Reaction

Regulation of Pore Structure and Acidity of a ZSM-5 Catalyst for Dehydration of Glycerol to Acrolein

Ethanol Dehydration and Coke Evolution on a Submicron ZSM-5 Zeolite

Effect of Si Content on the Performance of Direct Synthesis of Dimethyl Ether over Slurry CuZnAl Catalyst Prepared by Complete Liquid Phase Technology

Complete Liquid Phase Preparation and Characterization of CuZnAlSi Catalysts for DME Synthesis in Slurry Reactor

Effect of Methanol on Catalytic Performance of Hy Zeolite for Desulfurization of Fcc Gasoline by Alkylation

High-Temperature Pretreatment Effect on Co/SiO 2 Active Sites and Ethane Dehydrogenation

Effect of coking and propylene adsorption on enhanced stability for Co2+-catalyzed propane dehydrogenation

Coking Behavior of Submicron ZSM-5 Zeolite Catalyst in Dehydration of Ethanol to Ethylene

Effect of Heat Treatment on the Structure,acidity and Catalytic Performance of HZSM-5 Zeolites in Ethanol Dehydration

Solvent Feedstock Effect: the Insights into the Deactivation Mechanism of Cu/SiO2 Catalysts for Hydrogenation of Dimethyl Oxalate to Ethylene Glycol.

EFFECTS OF CARBON AND SILICON DEPOSITION ON ACTIVITY OF HYDROGENATION CATALYST AND REGENERATION PERFORMANCE

Mildly Acidic Aluminosilicate Catalysts for Stable Performance in Ethanol Dehydration

The Pretreatment and Coking Behavior of Submicron ZSM-5 Zeolite Catalyst during Ethanol Dehydration

Chromium-based Catalysts for Ethane Dehydrogenation: Effect of SBA-15 Support

Effects of mesopore introduction on the stability of zeolites for 4-iso-Propylphenol dealkylation

Catalytic Performance and Coking Behavior of a Submicron HZSM‐5 Zeolite in Ethanol Dehydration

Passivated Surface of High Aluminum Containing ZSM-5 by Silicalite-1: Synthesis and Application in Dehydration Reaction

Chemical liquid deposition with polysiloxane of ZSM-5 and its effect on acidity and catalytic properties

Research on Si–Al Based Catalysts Prepared by Complete Liquid-Phase Method for DME Synthesis in a Slurry Reactor