Abstract:Methanol is a potential alternative fuel for heavy-duty engines to effectively reduce carbon emissions. On the other hand, unregulated emissions from methanol-fueled engines are harmful to the environment. The formaldehyde emission mechanism was investigated in this paper using a premixed laminar combustion experiment and a plug flow reactor (PFR) simulation with a detailed mechanism. Furthermore, the engine test was carried out on a heavy-duty spark ignition (SI) pure methanol engine with EGR to study the effects of the injection strategy, exhaust gas recirculation ratio (EGR), engine load, and speed on unregulated emissions. The high-pressure loop EGR system and port fuel injection system were adopted. Unregulated emissions were measured using a GC-2010 gas chromatography analyzer with a pulsed discharge helium ionization detector (PDHID) and Gs-OxyPLOT. Formaldehyde emission is the post-oxidation production of unburned methanol, according to the experiment and simulation, and it increases first, then decreases as the temperature rises. Unregulated emissions mainly consist of methanol and formaldehyde. The injection timing can be divided into two groups: 120 degrees CA to 300 degrees CA and 360 degrees CA to 780 degrees CA, where 0 degrees CA represents fire TDC. The BTE at alpha(inj) of 120 degrees CA to 300 degrees CA is lower than that at other alpha(inj), while methanol and formaldehyde emissions are the opposite. The temperature of unburned methanol post-oxidation is affected by engine speed, load, and EGR ratio, affecting methanol and formaldehyde emissions. The higher exhaust temperature caused by the higher engine speed, load and a lower EGR ratio can reduce methanol emissions. The nonmonotonic trends of formaldehyde emission with the EGR ratio and the different influences of EGR on the formaldehyde emission under different engine loads are the result of the nonmonotonic relationship between formaldehyde emission and temperature. The engine experiment results are consistent with the PFR simulation.

An Experimental Study of Unregulated Pollutants from a DME Fueled Diesel Engine

Investigations on Unregulated Pollutants from a DME Fueled Engine

Tiny Pollutant Emissions of a Dimethyl Ether Fuelled Engine

Experimental Research on Pollutant Emission from a DME HCCI Engine

Comprehensive Study on Unregulated Emissions of Heavy-Duty SI Pure Methanol Engine with EGR

Regulated And Nonregulated Emissions From A Dimethyl Ether Powered Compression Ignition Engine

Experimental Investigation of Regulated and Unregulated Emissions from a Diesel Engine Fueled with Euro V Diesel Fuel and Fumigation Methanol

Investigation on the regulated and unregulated emissions of a DME engine under different injection timing

An Investigation on Combustion and Exhaust Emissions of Direct Injection Diesel Engine Fuelled with Dimethyl Ether

Unregulated emissions from DMDF engines to meet with National V emission legislation

Experimental Investigation of Particulate Emissions from a Diesel Engine Fueled with Ultralow-Sulfur Diesel Fuel Blended with Diglyme

A Study on the Measurement Results of Formaldehyde Emissions from SI Engine Fueled with Methanol/Gasoline Blends by FTIR and Chromatography

Experimental Investigation on Regulated and Unregulated Emissions of a Diesel/methanol Compound Combustion Engine with and Without Diesel Oxidation Catalyst

Gas Emissions and Particulate Matter of Non-Road Diesel Engine Fueled with F-T Diesel with EGR

Experimental investigations of the effects of pilot injection on combustion and gaseous emission characteristics of diesel/methanol dual fuel engine

Characteristic of Regulated Emissions and Formaldehyde Emission from Turbocharged Inter-Cooled Diesel Engine with Diesel/Methanol Compound Combustion Mode

The characteristics of formaldehyde emissions in the diesel/methanol compound combustion system

Experimental Investigation of Unregulated Emissions Using Low-Percent Methanol-Gasoline Blend Fuels

Regulated and Unregulated Emissions from a Light-Duty Diesel Engine with Different Sulfur Content Fuels

Measurement of Formaldehyde Emission from Diesel/methanol Compound Combustion

Research of tiny pollutant from DME HCCI engines