Abstract:Most wastewater treatment reactors have problems such as slow start-up and a poor treatment effect. This study investigates the rapid start-up and optimal conditions of the expanded granular sludge bed (EGSB)–two-stage anaerobic/aerobic (A/O) biofilm process. The combined process was successfully started by gradually increasing the organic load for approximately 50 d, during which the organic loading rate increased from 4.6 to 46 kg·COD/(m3·d). By investigating the operation effect of the EGSB reactor at hydraulic retention times (HRTs) of 4, 6, 8, and 10 h, reflux ratios of 6:1, 7:1, 8:1, and 9:1, and ammonia concentrations of 200–800 mg/L, the optimal operation conditions were determined. In the two-stage A/O process, hollow cylindrical fillers and hollow spherical fibrous fillers were used to observe the growth of biofilms on different fillers. The sludge structure and microorganisms were analyzed by scanning electron microscopy and high-throughput sequencing. The results show that when the combined process was successfully started, the chemical oxygen demand removal rate was 97%, and the ammonia nitrogen removal rate was 73%. The EGSB reactor had the best operation effect under the conditions of a low ammonia concentration, HRT = 8 h and reflux ratio of 8:1. In the two-stage A/O process, the biofilm growth condition of the hollow column filler with a high specific surface area was better than that of the hollow spherical filler containing flocculent fibers. The microstructure of the sludge was conducive to the metabolism of microorganisms. The primary microorganisms at the phylum level mainly included Proteobacteria, Firmicutes, Synergistetes, Actinobacteria, and Chloroflexi. These findings provide a new idea for the treatment of high-concentration organic wastewater and reactor start-up.

Research on Start-Up of Suspended Bio-Film Process for Stream Treatment

Start-up Evaluations and Biocarriers Transfer from a Trickling Filter to a Moving Bed Bioreactor for Synthetic Mariculture Wastewater Treatment.

Synergistic Effect of Chitosan-Based Sludge Aggregates CS@NGS Inoculum Accelerated the Start-Up of Biofilm Reactor Treating Aquaculture Effluent: Insights into Performance, Microbial Characteristics, and Functional Genes.

Research on Nitrogen and Phosphorous Removal by Biofilm-Activated Sludge Process

Performance and microbial communities of different biofilm membrane bioreactors with pre-anoxic tanks treating mariculture wastewater

Studies on Start-Up Technique of Anammox Bioreactor

Study on Start-up and Operation of Anaerobic Attached Film Expanded Bed with Resin As Biofilm Carrier

Aquaculture wastewater treatment using a moving bed biofilm reactor( MBBR)

[Pilot Experiment on the Treatment of the River Wastewater by a Step-Feed Biological Contact Process].

Startup Pattern and Performance Enhancement of Pilot-Scale Biofilm Process for Raw Water Pretreatment.

Effects of Biofilm Growing Methods on Start-Up and Performances for Simulated River Bioreactor

Study on biofilm colonization in treatment of urban polluted river water

Influence of Inoculated Sludge Quantity on Start-up of Hybrid Biofilm Reactor

Research on the start-up performance of the two-double biological aerated filter for treating electroplating wastewater

Study on start-up processes of two-stage biological aerated filter

Low strength wastewater anammox start-up by stepwise decrement in influent nitrogen: Biofilm formation mechanism and mathematical modelling.

Biofilm Formation and Microbial Community Analysis of the Simulated River Bioreactor for Contaminated Source Water Remediation.

[Start-Up and Process Control of a Pilot-Scale Anammox Bioreactor at Ambient Temperature].

Performance Improvement of Raw Water Pretreatment Process with Pre-Inoculation Biofilm: Feasibility and Limiting Factors

[Study on the Start-Up of an Innovative Polyethylene Carrier Biotrickling Filter Treating Waste Gas Containing Hydrogen Sulphide].

Study on the start-up operation and sludge characteristics of organic wastewater treated by the EGSB–two-stage anaerobic/aerobic biofilm process