Abstract:Most wastewater treatment reactors have problems such as slow start-up and a poor treatment effect. This study investigates the rapid start-up and optimal conditions of the expanded granular sludge bed (EGSB)–two-stage anaerobic/aerobic (A/O) biofilm process. The combined process was successfully started by gradually increasing the organic load for approximately 50 d, during which the organic loading rate increased from 4.6 to 46 kg·COD/(m3·d). By investigating the operation effect of the EGSB reactor at hydraulic retention times (HRTs) of 4, 6, 8, and 10 h, reflux ratios of 6:1, 7:1, 8:1, and 9:1, and ammonia concentrations of 200–800 mg/L, the optimal operation conditions were determined. In the two-stage A/O process, hollow cylindrical fillers and hollow spherical fibrous fillers were used to observe the growth of biofilms on different fillers. The sludge structure and microorganisms were analyzed by scanning electron microscopy and high-throughput sequencing. The results show that when the combined process was successfully started, the chemical oxygen demand removal rate was 97%, and the ammonia nitrogen removal rate was 73%. The EGSB reactor had the best operation effect under the conditions of a low ammonia concentration, HRT = 8 h and reflux ratio of 8:1. In the two-stage A/O process, the biofilm growth condition of the hollow column filler with a high specific surface area was better than that of the hollow spherical filler containing flocculent fibers. The microstructure of the sludge was conducive to the metabolism of microorganisms. The primary microorganisms at the phylum level mainly included Proteobacteria, Firmicutes, Synergistetes, Actinobacteria, and Chloroflexi. These findings provide a new idea for the treatment of high-concentration organic wastewater and reactor start-up.

Study on start-up processes of two-stage biological aerated filter

Start-up Evaluations and Biocarriers Transfer from a Trickling Filter to a Moving Bed Bioreactor for Synthetic Mariculture Wastewater Treatment.

Investigating the conversion from nitrifying to denitrifying water-treatment efficiencies of the biofloc biofilter in a recirculating aquaculture system

Research on the start-up performance of the two-double biological aerated filter for treating electroplating wastewater

STUDY ON MUNICIPAL WASTEWATER TREATMENT USING SLAG FILTERS IN BIOLOGICAL AERATED FILTER WITH PRE-DENITRIFICATION

Comparison of start-up characteristics and odorant removal efficiencies of biological aerated filters differentho in filling

Application of Two Stage BAF in Domestic Wastewater Reuse

The Study Status on BAF's Technics

STUDY OF BAF FOR DYEING WASTEWATER ADVANCED TREATMENT

Electroplating wastewater treatment with a two-double biological aerated filter (T-DBAF) for reuse

Characterization and Quantification of Anammox Start-Up in UASB Reactors Seeded with Conventional Activated Sludge

[Effect of Sequential Biocatalyst Addition on Anammox Process].

Research on the removal mechanism of pollutants using Biological Aerated Filter

Pilot-scale Study on Polluted River Water Treatment by G-BAF

Study on the start-up operation and sludge characteristics of organic wastewater treated by the EGSB–two-stage anaerobic/aerobic biofilm process

Studies on Start-Up Technique of Anammox Bioreactor

Enhanced nitrogen removal of aquaculture wastewater in the combined biological aerated filter: the effect of GAC location setting

MOST RECENT DEVELOPMENT AND APPLICATION OF BIOLOGICAL AERATED FILTER

Seeding Sludge and Start-up Strategy for Anammox Bioreactor

Simultaneous Nutrients and Carbon Removal from Low-Strength Domestic Wastewater with an Immobilised-Microorganism Biological Aerated Filter

Comparative Study on Biological Activated Carbon Fluidized Bed and Conventional Activated Sludge Treating Domestic Sewage