Abstract:Most wastewater treatment reactors have problems such as slow start-up and a poor treatment effect. This study investigates the rapid start-up and optimal conditions of the expanded granular sludge bed (EGSB)–two-stage anaerobic/aerobic (A/O) biofilm process. The combined process was successfully started by gradually increasing the organic load for approximately 50 d, during which the organic loading rate increased from 4.6 to 46 kg·COD/(m3·d). By investigating the operation effect of the EGSB reactor at hydraulic retention times (HRTs) of 4, 6, 8, and 10 h, reflux ratios of 6:1, 7:1, 8:1, and 9:1, and ammonia concentrations of 200–800 mg/L, the optimal operation conditions were determined. In the two-stage A/O process, hollow cylindrical fillers and hollow spherical fibrous fillers were used to observe the growth of biofilms on different fillers. The sludge structure and microorganisms were analyzed by scanning electron microscopy and high-throughput sequencing. The results show that when the combined process was successfully started, the chemical oxygen demand removal rate was 97%, and the ammonia nitrogen removal rate was 73%. The EGSB reactor had the best operation effect under the conditions of a low ammonia concentration, HRT = 8 h and reflux ratio of 8:1. In the two-stage A/O process, the biofilm growth condition of the hollow column filler with a high specific surface area was better than that of the hollow spherical filler containing flocculent fibers. The microstructure of the sludge was conducive to the metabolism of microorganisms. The primary microorganisms at the phylum level mainly included Proteobacteria, Firmicutes, Synergistetes, Actinobacteria, and Chloroflexi. These findings provide a new idea for the treatment of high-concentration organic wastewater and reactor start-up.

Research on the start-up performance of the two-double biological aerated filter for treating electroplating wastewater

Electroplating wastewater treatment with a two-double biological aerated filter (T-DBAF) for reuse

Study on start-up processes of two-stage biological aerated filter

Start-up Evaluations and Biocarriers Transfer from a Trickling Filter to a Moving Bed Bioreactor for Synthetic Mariculture Wastewater Treatment.

[Start-Up of a Full-Scale System for Short-Cut Nitrification and Anammox in Treatment of Pharmaceutical Wastewater].

ELECTROCATALYTIC OXIDATION OF ORGANIC POLLUTANTS IN ELECTROPLATING WASTEWATER IN PILOT SCALE

Aquaculture wastewater treatment using a moving bed biofilm reactor( MBBR)

[Effect of Sequential Biocatalyst Addition on Anammox Process].

Biological Nutrient Removal in A Sequencing Batch Reactor Operated As Oxic/Anoxic/Extended-Idle Regime

Studies on Start-Up Technique of Anammox Bioreactor

Startup Pattern and Performance Enhancement of Pilot-Scale Biofilm Process for Raw Water Pretreatment.

Study on the start-up operation and sludge characteristics of organic wastewater treated by the EGSB–two-stage anaerobic/aerobic biofilm process

STUDY ON MUNICIPAL WASTEWATER TREATMENT USING SLAG FILTERS IN BIOLOGICAL AERATED FILTER WITH PRE-DENITRIFICATION

Study on Start-up Performance of Seepage Biological Bed (SBB) for Purifying Polluted River Water

Pretreatment of Urban Polluted River Water by Biological Aerated Filter

Effects of an electrocoagulation–air flotation–microfiltration pretreatment process on the start-up of a moving bed biofilm reactor: performance and microbial community structure

Engineering Project of Electroplating Wastewater Toxic Pollutants Advanced Treatment Based on Resins Adsorption

Salt chemical industrial wastewater treatment using hydrolysis-combined biological filter process

Enhanced removal of contaminant using the biological film, anoxic-anaerobic-aerobic and electro-coagulation process applied to high-load sewage treatment

Study on Pollutants Removal Efficiency of A~2/O/A/MBR Pilot Device

[Pilot Experiment on the Treatment of the River Wastewater by a Step-Feed Biological Contact Process].