Abstract:Most wastewater treatment reactors have problems such as slow start-up and a poor treatment effect. This study investigates the rapid start-up and optimal conditions of the expanded granular sludge bed (EGSB)–two-stage anaerobic/aerobic (A/O) biofilm process. The combined process was successfully started by gradually increasing the organic load for approximately 50 d, during which the organic loading rate increased from 4.6 to 46 kg·COD/(m3·d). By investigating the operation effect of the EGSB reactor at hydraulic retention times (HRTs) of 4, 6, 8, and 10 h, reflux ratios of 6:1, 7:1, 8:1, and 9:1, and ammonia concentrations of 200–800 mg/L, the optimal operation conditions were determined. In the two-stage A/O process, hollow cylindrical fillers and hollow spherical fibrous fillers were used to observe the growth of biofilms on different fillers. The sludge structure and microorganisms were analyzed by scanning electron microscopy and high-throughput sequencing. The results show that when the combined process was successfully started, the chemical oxygen demand removal rate was 97%, and the ammonia nitrogen removal rate was 73%. The EGSB reactor had the best operation effect under the conditions of a low ammonia concentration, HRT = 8 h and reflux ratio of 8:1. In the two-stage A/O process, the biofilm growth condition of the hollow column filler with a high specific surface area was better than that of the hollow spherical filler containing flocculent fibers. The microstructure of the sludge was conducive to the metabolism of microorganisms. The primary microorganisms at the phylum level mainly included Proteobacteria, Firmicutes, Synergistetes, Actinobacteria, and Chloroflexi. These findings provide a new idea for the treatment of high-concentration organic wastewater and reactor start-up.

Study on Start-up and Operation of Anaerobic Attached Film Expanded Bed with Resin As Biofilm Carrier

Investigation on Start-Up and Operation of an Anaerobic Attached Microbial Film Expanded Bed with Ceramisites As Biofilm Carrier

CHARACTERISTICS OF SLUDGE IN ANAEROBIC ATTACHED FILM EXPANTION BED WITH RESIN AS BIOFILM CARRIER

Enhanced Aquaculture Wastewater Treatment in a Biofilm Reactor Filled with Sponge/ferrous Oxalate/biochar Composite (Sponge-C2feo4@nbc) Biocarriers: Performance and Mechanism

Synergistic Effect of Chitosan-Based Sludge Aggregates CS@NGS Inoculum Accelerated the Start-Up of Biofilm Reactor Treating Aquaculture Effluent: Insights into Performance, Microbial Characteristics, and Functional Genes.

[Performance of ANAMMOX Attached Microbial Film Expanded Bed Reactor].

Hydraulic flow pattern and performance of swirling flow anaerobic attached growth film expanded bed bioreactor

Study on the start-up operation and sludge characteristics of organic wastewater treated by the EGSB–two-stage anaerobic/aerobic biofilm process

Advanced start-up of anaerobic attached film expanded bed reactor by pre-aeration of biofilm carrier.

Research and application of anaerobic granular sludge suspended bed reactor

Rapid start-up and long-term stable operation of the anammox reactor based on biofilm process: Status, challenges, and perspectives

ADVANCED TREATMENT OF SIMULATED SWINE WASTEWATER BY A MOVING BED BIOFILM REACTOR

Improvement of start-up and nitrogen removal of the anammox process in reactors inoculated with conventional activated sludge using biofilm carrier materials

Enhanced aerobic granulation, stabilization, and nitrification in a continuous-flow bioreactor by inoculating biofilms

Biofilm growth characterization and treatment performance in a single stage partial nitritation/anammox process with a biofilm carrier

COD removal from expanded granular sludge bed effluent using a moving bed biofilm reactor and their microbial community analysis

A mainstream anammox fixed-film membrane bioreactor with novel sandwich-structured carriers for fast start-up, effective sludge retention and membrane fouling mitigation

CHARACTERISTICS OF WASTEWATER TREATMENT BY A FIXED-BED BIOREACTOR WITH POROUS MICROBIAL CARRIERS

Start-up of fixed carrier anaerobic reactor treatment to molasses wastewater

Influence of Inoculated Sludge Quantity on Start-up of Hybrid Biofilm Reactor

The co-existence of anammox genera in an expanded granular sludge bed reactor with biomass carriers for nitrogen removal