Abstract:Deep-sea mud has received significant attention from the international community as a novel resource of rare earth elements (REEs). In this study, a novel approach is proposed for the recovery of REEs from deep-sea mud. The mud samples were characterized, and the occurrence states of REEs were clarified. The results revealed that REEs in mud occur almost entirely in hydroxyapatite minerals, which can be easily reached via acid leaching. The optimized leaching percentage of REEs reaches 89.50 %, 88.94 %, 83.81 %, and 86.52 %, respectively, by using 2.0 mol/L HCl, 2.0 mol/L HNO 3 , 1.0 mol/L H 2 SO 4 , and 2.0 mol/L H 3 PO 4 as leaching agents with a liquid–solid ratio of 4:1 and a stirring speed of 300 r/min at 60 °C for 30 min. After that, the REEs were leached into the leaching solution along with the impurities of Al, Fe, Mn, Ca, and Mg. The sulfate leaching solutions were directly used for solvent extraction of REEs using N1923 and TBP. A total of 97.50 % REEs and 100 % Fe were co-extracted through five-stage countercurrent extraction using an organic system consisting of 10 %(v/v) N1923 and 10 %(v/v) TBP in sulfonated kerosene at an O/A ratio of 1:1.4. In contrast, the percentage extraction of other metals was negligible. Furthermore, 99.33 % REEs in the loaded organic system were selectively stripped through a five-stage countercurrent stripping process using the (0.1 mol/L HCl + 4.9 mol/L NaCl) solutions with an O/A ratio of 1:1, leaving Fe in the organic system. The remaining Fe-loaded organic material could be stripped using a 0.5 mol/L HNO 3 solution followed by Na 2 CO 3 neutralization for regeneration. Finally, 98.81 % of the REEs in the stripped solution were precipitated through Na 2 C 2 O 4 precipitation followed by calcination at 900°Cfor 120 min. Throughout the entire separation and purification process, 80.20 % of REEs in the deep-sea mud resource were recovered as pure enrichment of REEs oxide with a content of 81.82 %, while Al, Fe, Mg, Ca, Mn, and P were less than 0.15 %.

Recovery of rare earth elements from Dicranopteris dichotoma by an enhanced ion exchange leaching process

Basis for a new process for producing REE oxides from Dicranopteris linearis

A New Method for Recovering Rare Earth Elements from the Hyperaccumulating Fern Dicranopteris Linearis from China

Selective recovery of rare earth elements and value-added chemicals from the Dicranopteris linearis bio-ore produced by agromining using green fractionation

REE Recovery from the Fern <Emphasis Type="Italic">D. Dichotoma</Emphasis> by Acid Oxalic Precipitation After Direct Leaching with EDTA

An eco-friendly and high-yield extraction of rare earth from the leaching solution of ion adsorbed minerals

Recovering RE from leaching liquor of rare earth ore by extraction

Effective Recovery of Rare Earth from (bio)leaching Solution Through Precipitation of Rare Earth-Citrate Complex

Bioleaching Ion-Unexchangeable Rare Earth in Ion-Adsorption Type Rare Earth Waste Tailing

Recovery of Rare Earth Elements from Acidic Mine Waters: A circular treatment scheme utilizing selective precipitation and ion exchange

Recovery of rare earth elements from acid mine drainage by ion exchange

Recovery of rare earth elements from deep-sea mud using acid leaching followed by selective solvent extraction with N1923 and TBP

Element Case Studies: Rare Earth Elements

A Novel Process for Recovering Rare Earth from Weathered Black Earth

Recovery of Rare Earths from Nitric Acid Leach Solutions of Phosphate Ores Using Solvent Extraction with a New Amide Extractant (TODGA)

Recovery of rare earth elements from spent fluid catalytic cracking catalysts using leaching and solvent extraction techniques

Recovering REEs from NdFeB Wastes with High Purity and Efficiency by Leaching and Selective Precipitation Process with Modified Agents

Efficient Enrichment and Recovery of Rare Earth Elements with Low Concentration by Membrane Dispersion Micro-Extractors

Vacuum pyrolysis method for reclamation of rare earth elements from hyperaccumulator Dicranopteris dichotoma grown in contaminated soil

One-step Enrichment of Rare Earth Elements from Ionic Rare Earth Leachate by Electrochemical Precipitation

What are the different biomolecules involved in the selective recovery of REEs from mining wastewater using FeNPs synthesized from two plant extracts?