Abstract:Methyl decanoate, methyl-5-decenoate and methyl-9-decenoate have been widely adopted as biodiesel surrogates for engine simulation. However, these surrogates have relatively short chain length and very different physical properties compared with biodiesel molecules. Additionally, it is difficult to distinguish the unsaturafion degree of different biodiesel fuels by using these surrogates. The direct use of the heavy methyl esters in real biodiesel fuels as surrogates is essential to accurately simulate biodiesel fuels. In this work, a four-part scheme to formulate skeletal mechanism for heavy saturated methyl esters has been proposed. Within the scheme, the oxidation mechanism is divided into four parts: low temperature oxidation, high temperature decomposition, ester group reactions and detailed C4-C0 chemistry. A skeletal mechanism for two of the five main methyl esters in real biodiesel fuels, i.e. saturated methyl palmitate and methyl stearate, has been constructed. The obtained skeletal mechanism contains only 6 fuel-dependent species and 13 fuel-dependent reactions for each heavy saturated methyl ester. Extensive validations were performed against shock tube experimental data for ignition delay timing under different initial pressure, temperature and equivalence ratio. The ignition delay behavior at high temperature has been well captured by the developed skeletal mechanism. As for ignition at low to medium temperature (from 650 K to 900 K), there is no experimental data due to the low vapor pressure and high melting point of heavy methyl esters. The comparison of ignition behavior at low temperature has been made between several models. Furthermore, the oxidation of n-decane/methyl palmitate and benzene/methyl stearate in a jet-stirred reactor has been utilized to validate the important species concentration. Good agreements have been observed through the validations. The results indicate that the developed skeletal mechanism is capable of predicting the combustion characteristics of methyl palmitate and methyl stearate.

Experimental Investigations on the Liquid Thermal Conductivity of Five Saturated Fatty Acid Methyl Esters Components of Biodiesel

Measurement on the Thermal Conductivity of Five Saturated Fatty Acid Ethyl Esters Components of Biodiesel

Experimental Studies on the Thermal Conductivity of Methyl Laurate Component of Biodiesel with Three Alcohols

Thermal Conductivity of the Binary Mixtures of N-Heptane and Fatty Acid Esters: Measurement and Correlation

Experiment Investigation on the Liquid Thermal Conductivity of Biodiesel + Diesel Fuel Blends

Measurement of the Thermal Conductivity of Biofuel Mixtures: Methyl Caprate Components of Biodiesel and Alcohols

Experimental Investigations on the Thermophysical Properties of Methyl Myristate in Alcoholic Solutions

Measurement and Correlation of the Density, Viscosity and Vapor Pressure of Fatty Acid 2-Ethyhexyl Esters

Experimental investigation of liquid thermal diffusivity for fatty acid methyl/ethyl esters by dynamic light scattering method

Measurement of sound speed in methyl caprate, methyl laurate and methyl myristate

Densities and Excess Molar Volumes of Methanol with Three Fatty Acid Methyl Esters from 283.15 to 318.15 K

Skeletal Mechanism Construction for Heavy Saturated Methyl Esters in Real Biodiesel Fuels

General Models for Prediction Densities and Viscosities of Saturated and Unsaturated Fatty Acid Esters

Speed of Sound in Methyl Caprate, Methyl Laurate, and Methyl Myristate: Measurement by Brillouin Light Scattering and Prediction by Wada’s Group Contribution Method

On the Laminar Flame Propagation of C5H10O2 Esters Up to 10 Atm: A Comparative Experimental and Kinetic Modeling Study

Experimental study on isobaric specific heat capacities of methyl myristate at elevated pressures

Measurement of Sound Speed and Derived Properties of Three FAMEs

Thermal Hydraulics and Thermochemical Design of Fatty Acid Methyl Ester (Biodiesel) Esterification Reactor by Heating with High Boiling Point Phenyl-Naphthalene Liquid

Measurement of Speed of Sound and Thermal Diffusivity of Ethyl Heptanoate Using Light Scattering Method

Measurements of the Thermal Conductivity of Three Pure Alcohols and Their Binary Mixtures with Methyl Myristate Component of Biodiesel

Experimental Study on Combustion and Emission Characteristics of Fatty Acid Methyl Esters and Hydrogenated Catalytic Biodiesel/diesel Blends under World Harmonized Steady State Cycle