Efficient SO 2 Removal and Highly Synergistic H 2 O 2 Production Based on a Novel Dual-Function Photoelectrocatalytic System
Xiaojie Mei,Jing Bai,Shuai Chen,Mengyang Zhou,Panyu Jiang,Changhui Zhou,Fei Fang,Yan Zhang,Jinhua Li,Mingce Long,Baoxue Zhou
DOI: https://doi.org/10.1021/acs.est.0c00886
2020-08-04
Abstract:The direct conversion of SO<sub>2</sub> to SO<sub>3</sub> is rather difficult for flue gas desulfurization due to its inert dynamic with high reaction activation energy, and the absorption by wet limestone-gypsum also needs the forced oxidation of O<sub>2</sub> to oxidize sulfite to sulfate, which is necessary for additional aeration. Here, we propose a method to remove SO<sub>2</sub> with highly synergistic H<sub>2</sub>O<sub>2</sub> production based on a novel dual-function photoelectrocatalytic (PEC) system in which the jointed spontaneous reaction of desulfurization and H<sub>2</sub>O<sub>2</sub> production was integrated instead of nonspontaneous reaction of O<sub>2</sub> to H<sub>2</sub>O<sub>2</sub>. SO<sub>2</sub> was absorbed by alkali liquor then oxidized quickly into SO<sub>4</sub><sup>2–</sup> by a nanorod α-Fe<sub>2</sub>O<sub>3</sub> photoanode, which possessed high alkali corrosion resistance and electron transport properties. H<sub>2</sub>O<sub>2</sub> was produced simultaneously in the cathode chamber on a gas diffusion electrode and was remarkably boosted by the conversion reaction of SO<sub>3</sub><sup>2–</sup> to SO<sub>4</sub><sup>2–</sup> in the anode chamber in which the released chemical energy was effectively used to increase H<sub>2</sub>O<sub>2</sub>. The photocurrent density increased by 40% up to 1.2 mA·cm<sup>–2</sup>, and the H<sub>2</sub>O<sub>2</sub> evolution rate achieved 58.8 μmol·L<sup>–1</sup>·h<sup>–1</sup>·cm<sup>–2</sup> with the synergistic treatment of SO<sub>2</sub>, which is about five times than that without SO<sub>2</sub>. This proposed PEC cell system offers a cost-effective and environmental-benign approach for dual purpose of flue gas desulfurization and simultaneous high-valued H<sub>2</sub>O<sub>2</sub> production.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.est.0c00886?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.est.0c00886</a>.Schematic illustration of the PEC process with SO<sub>2</sub> removal and H<sub>2</sub>O<sub>2</sub>, schematic diagram of the adsorption device and technological process, <i>J</i>–<i>V</i> curves of different SO<sub>2</sub> removal electrolytes with different anodes (scan rate: 10 mV·s<sup>–1</sup>), amperometric <i>i</i>–<i>t</i> curve of the hematite electrode with in situ increase in the concentration of Na<sub>2</sub>SO<sub>3</sub> at an applied potential of 0.5 V vs. Ag/AgCl, equivalent circuit (EC) of the charge transfer process at the hematite/electrolyte interface, calculation results of the charge transfer process based on the equivalent circuit, photocurrent densities of hematite in solutions with different pH values, effects of coexistent flue gas on SO<sub>2</sub> removal, effects of temperature on SO<sub>2</sub> removal, schematic illustration of the PEC process with SO<sub>2</sub> removal and H<sub>2</sub>O<sub>2</sub> generation, tendency of pH changes of the anode and cathode electrolyte in 90 min, Koutecký–Levich plots of the GDE based on LSV curves measured by a rotating disk electrode, SEM images of the hematite photoanode before and after long-time running, morphology of the GDE before and after long-time running, tendency of pH changes of the anode and cathode electrolyte in 20 h, and raw material cost of the electrodes in the PEC process for dealing with SO<sub>2</sub> generated from 1 MWh electricity (<a class="ext-link" href="/doi/suppl/10.1021/acs.est.0c00886/suppl_file/es0c00886_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.
environmental sciences,engineering, environmental