Abstract:The effects of counter-surface chemistry and adsorption of water and alcohol from the environment on the tribological responses of silicon surfaces were investigated using atomic force microscopy. When scratching with SiO 2 tips at contact pressures below the hardness of the materials, changing the environment yielded drastically different wear behaviors. In humid air, the adsorbed water molecules facilitated wear of the surface and material removal. In N 2 environment, there was subsurface deformation but no wear, so the surface protruded outward in the rubbing region. In the ethanol vapor condition, the adsorbed alcohol molecules acted as a lubricant and prevented any discernible changes to the surface even at contact pressures above 1 GPa. These results extend upon previous studies of vapor-phase alcohol lubrication using even more protective longer-chain alcohols where failure was observed at much lower contact pressures in macroscale tests, probably due to high-pressure asperity contacts. Thus, the chemical environment can govern the response of silicon to mechanical rubbing. Rubbing with a diamond tip, however, yielded protrusions in all three environments, showing that the chemistry of the counter-surface also contributes to the tribological response; in this case, diamond is not tribochemically reactive toward Si surface. The protrusion formed by the diamond tip in ethanol vapor was only ~20 % the height of the one in humid air, even though the measured friction coefficients (and so the applied shear forces) were similar. These results clearly show that the surface chemistry at the tribological interface can substantially alter both the wear and subsurface damage processes.

Effect of Abrasive Particle Size on Tribochemical Wear of Monocrystalline Silicon

Friction and Wear Studies of Octadecyltrichlorosilane SAM on Silicon

Wear Behaviour and Microstructural Changes of SiCw-Al Composite under Unlubricated Sliding Friction

Exploring the Effect of Nanoparticle Size on the Tribological Properties of Sio2 / Polyalkylene Glycol Nanofluid under Different Lubrication Conditions

Atomic Insight into Tribochemical Wear Mechanism of Silicon at the Si/SiO2 Interface in Aqueous Environment: Molecular Dynamics Simulations Using ReaxFF Reactive Force Field

Size Dependence of Nanoscale Wear of Silicon Carbide

Effects of Vapor Environment and Counter-Surface Chemistry on Tribochemical Wear of Silicon Wafers

Understanding of the effect of wear particles removal from the surface on grinding silicon carbide by molecular dynamics simulations

The Exposure Height of Silicon Particle with Round Edges Effect on the Tribological Property of Al-Si Alloy Cylinder Liner

Tribochemical Mechanism of Amorphous Silica Asperities in Aqueous Environment: a Reactive Molecular Dynamics Study.

Effect of Contact Forms on the Wear of Hard Silicon Surfaces by Soft Polymers

From atomic attrition to mild wear at multi-asperity interfaces: The wear of hard Si3N4 repeatedly contacted against soft Si

Correlation between serum lipids and 1-hour postload plasma glucose levels in normoglycemic individuals.

Study on the effect of particle size and dispersion of SiO2 on tribological properties of nitrile rubber

Effect of Abrasive Particle Size on Anti-Abrasion Performance of Si3N4 Ceramics

Effect of Surface Energy on the Wear Process of Bulk-Fabricated Mems Devices

Particle type effect on mechanisms of surface texturing in reducing wear

Experimental Investigation of Tip Wear of AFM Monocrystalline Silicon Probes

Investigating the effect of nanoscale triboelectrification on nanofriction in insulators

The Size Effect of SiO2 Particles on Friction Mechanisms of a Composite Friction Material

Effect of Si Content on the Tribological Properties of Crsin Films in Air and Water Environments