Abstract:To reduce carbon emissions, the application of hydrogen as a zero-carbon fuel in the field of internal combustion engines (ICEs) has become a hot topic in recent years. Meanwhile, the application of ignition methods such as turbulent jet ignition (TJI) in engines has been gradually attracting the interest of numerous scholars. However, there is a lack of research on the performance of the hydrogen-fueled engine with passive pre-chamber (PPC). This paper aims to explore the combustion and emission performance of TJI hydrogen engines under different load conditions through experimental and numerical methods. This study is based on a Miller cycle engine equipped with the PPC, where hydrogen is injected directly into the cylinder. The operational characteristics of internal flow field characteristics, combustion, and energy conversion in the PPC are revealed by numerical. The engine operates at a speed of 1600 rpm and an excess air ratio (λ) of 1.8. The results show that at a manifold absolute pressure (MAP) of 40 kPa, the brake mean effective pressure (BMEP) is 0.95 bar, and the brake thermal efficiency (BTE) is 17.26 %, with the coefficient of variation (COV) of the indicated mean effective pressure (COV IMEP ) of 3.3 %. Although BMEP can be increased to 5.3 bar, BTE is 40.3 %, and COV IMEP can be reduced to 1.1 % under WOT, emissions have significantly increased. Additionally, the study explores the effect of variable valve timing (VVT) and spark timing (ST) on the performance of the hydrogen engine with PPC under partial load conditions. The results indicate that the ST has an insignificant influence on the power performance of TJI hydrogen engines, but delaying the ST could reduce nitrogen oxide (NOx) emissions. By appropriately delaying the timing of the intake valve opening (IVO), not only the power performance of TJI hydrogen engines could be improved, but also the COV IMEP could be reduced.

Effects of Initial Temperature on the Performances of Free Piston Linear Generator

Effect of key parameter on the energy consumption and start-up time in the cold start-up process of an opposed-piston free-piston linear generator

Numerical Investigation on the Indicated Mean Effective Pressure and Integral Heat Release Rate Variations under Different Key Operating Parameters of a Spark‐Ignited Free Piston Engine Generator

Numerical Investigations of Injection Timing Effects on a GDI Engine Performance: Part B, In-Cylinder Emission Formation and Oxidation Process

Effect of piston bowl geometry and compression ratio on in-cylinder combustion and engine performance in a gasoline direct-injection compression ignition engine under different injection conditions

Numerical Investigation of the Effect of Injection Timing on the In-Cylinder Activity of a Gasoline Direct Injection Engine

The effects of design parameters on the dynamic performance, in-cylinder pressure and electrical power generation of a free piston linear engine

Effects of Intake Temperature on the Gasoline/N-Heptane HCCI Combustion and Emissions in Gasoline Engine

Research on the impacts of operating frequency at combustion process for opposed single-cylinder free piston generator under direct injection

Effects of Intake Air Temperature on Homogenous Charge Compression Ignition Combustion and Emissions with Gasoline and N-Heptane

Estimation of Piston Surface Temperature During Engine Transient Operation for Emissions Reduction

A numerical investigation on the effects of gaseous fuel composition in a pilot ignited direct injection natural gas engine

Quantitative comparison of the operating characteristics and engine performances of typical configurations of free-piston engine linear generator

Effects analysis on soot combustion performance enhancement of an improved catalytic gasoline particulate filter regeneration system with electric heating

Simulation of a Two-Stroke Free-Piston Engine for Electrical Power Generation

Effects of piston shapes and swirl ratios on combustion and emissions of a natural gas engine ignited by micro diesel pilot

Effect of Temperature Conditions on Flame Evolutions of Turbulent Jet Ignition

Influences of the Control Parameters and Spark Plug Configurations on the Performance of a Natural Gas Spark-Ignition Engine

Study on the effect of variable valve timing and spark timing on the performance of the hydrogen-fueled engine with passive pre-chamber ignition under partial load conditions

Influences of Nonlinear Parameters on the Performance of a Free‐piston Stirling Engine

Effect of the Air Temperature on Combustion Characteristics and Nox Emissions from A 0.5 Mw Pulverized Coal-Fired Furnace with Deep Air Staging