Abstract:An in-depth insight into the pyrolysis characteristics of tobacco is of great significance for the utilization of tobacco wastes. The effects of glycerol addition on the pyrolysis characteristics and distribution of aroma components of four types of tobacco was investigated in this study by using thermogravimetry and self-built rapid heating furnace capture and GC-MS analysis. Further, correlation network analysis was used to study the correlation between pyrolysis characteristics and released aroma components. It was found that the thermal weight loss behavior of different samples exhibited both commonalities and differences, the thermal weight loss process could be divided into four stages. After the application of glycerol, the overall performance of all types of tobacco leaves at stage II showed that DTG max2 and WL 2 increased, and glycerol had a relatively obvious effect on the pyrolysis characteristic parameters of flue-cured tobacco. Pyrolysis kinetic analysis based on Coats-Redfern method showed that the activation energy and pre-exponential factor of tobacco samples were decreased after the addition of glycerol. Under the heating condition, the total amount of released aroma components from each type of tobacco followed the order of burley tobacco > flue-cured tobacco >oriental tobacco > yellow sun-cured tobacco. The release amount of heterocyclic and olefins compounds from burley tobacco were higher, while flue-cured tobacco released higher contents of esters, ketones and furans compounds. The addition of glycerol promoted the release of aroma components. In terms of correlation, T max2 was negatively correlated with esters, aldehydes, and furans compounds, and positively correlated with DTG max3 . T max3 was significantly correlated with a lot of indicators, positively with acids, aldehydes, and furans compounds, but negatively with olefins and heterocyclic compounds.

Trapping and Analysis of Aroma Components Released from Tobacco During Redrying

Determination of the low boiling point components in tobacco by thermal desorption-gas chromatography-mass spectrometry

Effects of different tobacco materials on the release characteristics of aroma components

Evaluation of Aroma Components in Chinese Southwest Tobacco by Headspace Gas Chromatography-Mass Spectrometry

Research on thermal decomposition behavior of components in different parts of tobacco

Multivariate Analysis of the Volatile Components in Tobacco Based on Infrared-Assisted Extraction Coupled to Headspace Solid-Phase Microextraction and Gas Chromatography-Mass Spectrometry.

Multiple analyses of main flavor components in reconstituted tobacco and transfer behavior of their key substances during heating

Pyrolysis characteristics of different types of tobacco and its correlation with the released aroma components under heating condition

Revealing the differences in aroma of black tea under different drying methods based on GC-MS, GC-O

Relationships between Climatic Factors and Chemical Components of Flue-cured Tobacco Leaves in Liangshan

Separation flavor components from Yunnan tobacco extraction by molecular distillation and GC-MS analysis

Analysis of Chemical Components in Tobacco Flavors Using Stir Bar Sorptive Extraction and Thermal Desorption Coupled with Gas Chromatography-Mass Spectrometry

Research progress of sample preparation and analytical techniques of aroma components in tobacco leaves

Unraveling the Difference in the Composition/Content of the Aroma Compounds in Different Tobacco Leaves: For Better Use

Analysis of differences in tobacco leaf microbial communities after redrying in Chinese provinces and from abroad

Research on the Heat Transfer and Mass Transfer of Tobacco During Drying Process in Tobacco Redryer

Study on Cut Tobacco Drying Process Based on HS-GC/MS: Principal Component Analysis, Similarity Analysis, Drying Conditions, and Drying Mechanism

Effect of different combined moistening and redrying treatments on the physicochemical and sensory capabilities of smoking food tobacco material

Effect of glycerol addition and heating rate on the thermal release behavior of cigar tobacco

Cluster Analysis of Characteristic Volatile Component in Flue-cured Tobacco Leaves from Liangshan and Yibin and Producing Area Discrimination of the Same

Dynamic Variations of Aglycon Aroma Components and Contents in Tobacco Leaves from Different Producing Areas at Later Growth Stage