Abstract:PtNi alloy nanoparticles supported on carbon (XC-72) are synthesized via a one-pot synthetic approach. This synthesized bimetallic composite offers several advantages, such as reduction of precious Pt along with an increase in activity due to the modified electronic structure. The prepared PtNi/C catalysts were employed as catalysts for NO removal both in a fixed-bed reactor and in a newly designed gas diffusion reactor. The performances of all prepared PtNi/C catalysts were higher than Pt/C at the same conditions and maintained a stable NO removal at a wide temperature window (100-300 degrees C), especially for Pt65Ni35 (more than 95% from 120 to 300 degrees C). This is attractive for low temperature SCR technology. According to XPS analysis, the surface layer phase was comprised of Pt contents with Ni being localized beneath the successive layers until Ni content increased to 67% mole ratio. The surface presence of Ni significantly affects the Pt electronic structure and raises the mass specific activity of Pt. Meanwhile, PtNi/C catalysts were introduced in a new gas diffusion reactor to remove NO under quantitatively less catalysts (30 mg), high NO concentration (1000 ppm), and at a high flow rate (resulting in a very short residence time of 0.09 s) condition. NO removal reaches almost 100% below 95 degrees C for all the PtNi catalysts and among all Pt65Ni35 exhibited the best performance. In addition, the influence of SO2 on the performance of Pt65Ni35 was also investigated, and the catalysts exposed a good antipoisonous property. The excellent performance of PtNi catalysts and a gas diffusion reactor are strongly recommended for their utilization as highly active and economical technology for NO removal.

SO 2 -tolerant and H 2 O-promoting Pt/C catalysts for efficient NO removal via fixed-bed H 2 -SCR

Low-Temperature Performance of Pt/Tio2 for Selective Catalytic Reduction of Low Concentration No by C3h6

Flexible monolithic Pt/CuO-Fe2O3/TiO2 catalysts integrated on Ti mesh for efficient NO removal via CO-SCR reaction

Highly Selective Catalytic Reduction of No Via So2/H2o-Tolerant Spinel Catalysts at Low Temperature

Negatively Charged Single-Atom Pt Catalyst Shows Superior SO 2 Tolerance in NO x Reduction by CO

Negatively Charged Single-Atom Pt Catalyst Shows Superior SO2 Tolerance in NOx Reduction by CO

Facile Synthesis of PtxNiy Catalyst Supported on Carbon for Low Temperature H2–SCR

Low-temperature SCR of NO with propylene in excess oxygen over the Pt/TiO2 catalyst

Characterization and Performance of Pt/SBA-15 for Low-Temperature SCR of NO by C3H6

Ultrafine Pt Particles Directed by Polyvinylpyrrolidone on Zeolite Beta As an Efficient Low-Temperature H2-SCR Catalyst

Highly Efficient Mesoporous V2O5/WO3–TiO2 Catalyst for Selective Catalytic Reduction of NOx: Effect of the Valence of V on the Catalytic Performance

Simultaneous Reduction of NOX and CO Harmful Gases According to the Promoters and Support Types of H2-SCR Catalyst

SO2 Promoted V2O5-MoO3/TiO2 Catalyst for NH3-SCR of NOx at Low Temperatures

Simultaneous removal of NO x and SO 2 by low-temperature selective catalytic reduction over modified activated carbon catalysts

TiO2 Coating on SiO2 Nanosphere Supported Pd Catalyst for the H2–SCR of NOx in the Presence of Oxygen

Selective Catalytic Reduction of Nitric Oxide by Hydrogen over NiFe2−xPdxO4 Catalysts at Low Temperature

Temperature-Dependent Effects of SO2 on Selective Catalytic Reduction of NO over Fe–Cu–OX/CNTs–TiO2 Catalysts

Low-temperature selective catalytic reduction of NO with propylene in excess oxygen over the Pt/ZSM-5 catalyst.

Effects of SO2 and H2O on low-temperature NO conversion over F-V2O5-WO3/TiO2 catalysts

Selective Catalytic Removal of High Concentrations of NOx at Low Temperature

Pt-Doped NiFe2O4 Spinel As a Highly Efficient Catalyst for H2 Selective Catalytic Reduction of NO at Room Temperature