Abstract:The higher voltage blocking capability and faster switching speed of silicon-carbide (SiC) mosfets have the potential to replace Si insulated gate bipolar transistors (IGBTs) in medium-low-voltage and high-power applications. In this paper, a state-of-the-art commercially available 325 A, 1700 V SiC mosfet module has been fully characterized under various load currents, bus voltages, and gate resistors to reveal their switching capability. Meanwhile, Si IGBT modules with similar power ratings are also tested under the same conditions. From the test results, several interesting points have been obtained: different to the Si IGBT module, the over-shoot current of the SiC mosfet module increases linearly with the increase of the load current and it has been explained by a model of the over-shoot current proposed in this paper; the induced negative gate voltage due to the complementary device turn-off (crosstalk effect) is more harmful to the SiC mosfet module than the induced positive gate voltage during turn-on when the gate off-voltage is 6 V; the maximum dvdt and didt (electromagnetic interference) during switching transients of the SiC mosfet module are close to those of the Si IGBT module when the gate resistance is larger than 8 but the switching loss of the SiC mosfet module is much smaller; the switching losses of the Si IGBT module are greater than those of the SiC mosfet module even when the gate resistance of the former is reduced to zero. An accurate power loss model, which is suitable for a three-phase two-level converter based on SiC mosfet modules considering the power loss of the parasitic capacitance, has been presented and verified in this paper. From the model, a 96.2 efficiency can be achieved at the switching frequency of 80kHz and the power of 100 kW.

Characterization, Modeling, and Application of 10-kV SiC MOSFET

10 Kv SiC MOSFET Based Boost Converter

ZVS range extension of 10A 15kV SiC MOSFET based 20kW Dual Active Half Bridge (DHB) DC-DC converter

Characteristics of 10 kV SiC MOSFET and PIN Diode and Their Application Prospect in High Voltage High Frequency DC/DC Converter

Dynamic Performance of 6.5kV/400A SiC MOSFET Module and its Gate Driver

Fabrication and Dynamic Switching Characteristics of 6.5kv400a SiC MOSFET Module

Sic Mosfet Zero-Voltage-Switching Svm Controlled Three-Phase Grid Inverter

Static and Dynamic Performance Characterization and Comparison of 15 Kv Sic Mosfet and 15 Kv Sic N-Igbts

Design of a 10 kV SiC MOSFET-based high-density, high-efficiency, modular medium-voltage power converter

An Accurate Analytical Model of SiC MOSFETs for Switching Speed and Switching Loss Calculation in High-Voltage Pulsed Power Supplies

Performance Evaluation of High-Power SiC MOSFET Modules in Comparison to Si IGBT Modules

3.38 Mhz Operation of 1.2kv SiC MOSFET with Integrated Ultra-Fast Gate Drive

Design and experimental analysis of a 1 kW, 800 kHz all-SiC boost DC-DC converter

Optimal Design of SiC MOSFETs for 20kw DCDC Converter

Design and Application of A 1200v Ultra-Fast Integrated Silicon Carbide Mosfet Module

A Sic Power Mosfet Loss Model Suitable for High-Frequency Applications

SiC MOSFET with built-in SBD for reduction of reverse recovery charge and switching loss in 10-kV applications

Characterization and Modeling of a 1.2-kV 30-A Silicon-Carbide MOSFET

10-kV SiC MOSFET Power Module With Reduced Common-Mode Noise and Electric Field