Abstract:In this paper, an optimized process for preparation of photosensitive nanosilica from rice husk (RH) is described. The rice husk sample was pretreated by soaking in deionized water to remove most of the alkali metals and partial fixed carbon. Most metal oxides, especially alkaline metal oxides and alkaline-earth metal oxides, were removed to a certain extent after the soaking pre-treatment. Soaking pretreatment may remove the hydrogen bonds or extractives between hemi-cellulose and cellulose, which affects the thermal stability of both molecules. To thoroughly analyze the soaking process, thermogravimetric analysis (TGA) was performed to obtain the mass loss behavior of soaked rice husk. The characteristics of the nanosilica prepared from the method described in this paper are superior to those of fumed silica. The silica content of the nanosilica reached a record of 99.92% in pyrolysis method. The optimum preparation conditions were as follows: a rice husk feedstock particle size of between 250 and 420 mu m, a pyrolysis temperature of approximately 610 degrees C, a hydrolysis temperature of 120 degrees C, a 1:10 (g/ml) ratio of rice husk to acid, a hydrolysis time of 4 h, and a hydrochloric acid (HCI) concentration of 8% (wt.%). A detailed study of the effects of the pyrolysis temperature and feedstock particle size was conducted, filling the gap in systematic research on the nanosilica preparation process using the pyrolysis method. The complete process of pyrolysis for pretreated rice husk is described, including the decomposition of the major constituents, volatilization of gases and the formation of silica. The results of this study provide a deep understanding of nanosilica production by pyrolyzation. The prepared nanosilica is photosensitive and approximately spheroidal with an average particle size of approximately 8-10 nm. (C) 2013 Elsevier B.V. All rights reserved.

A novel two-staged thermal synthesis method of generating nanosilica from rice husk via pre-pyrolysis combined with calcination

Preparation of highly dispersed nanosilica from rice husk by aprecipitation method combined with high pressure homogenization

A Detailed Study of the Effects of Pyrolysis Temperature and Feedstock Particle Size on the Preparation of Nanosilica from Rice Husk

Harvesting Silica Nanoparticles from Rice Husks

Synthesis of Rice Husk Nanosilica using the Hydrothermal Method

Nano?Silica Production by Rice Husk Combustion in a 0.7 MW Double?Circulating Fluidized Bed after Acid Pretreatment

A Sustainable Route For The Preparation Of Activated Carbon And Silica From Rice Husk Ash

Rapid and Facile Synthesis of Nanosized Silicalite-1 Zeolites from Solid Silica in a Semisolid-like System Via a Two-Step Crystallization Method

Rice husk ash as a renewable source for synthesis of sodium metasilicate crystal and its characterization

Kinetic study on the preparation of silica from rice husk under various pretreatments

Synthesis of Silicon Complexes from Rice Husk Derived Silica Nanoparticles

Synthesis of silica and carbon-based nanomaterials from rice husk ash by ambient fiery and furnace sweltering using a chemical method

A Comparative Study on Rice Husk, as Agricultural Waste, in the Production of Silica Nanoparticles via Different Methods

Efficient Utilization of Silanol Group in Rice Husk to Promote the Synthesis of Ni-phyllosilicate for CO2 Methanation

A Green Route to Preparation of Silica Powders with Rice Husk Ash and Waste Gas

Efficient utilization of silanol group in rice husk to promote the synthesis of Ni-phyllosilicate for CO 2 methanation

Synthesis and Characterization of Na-P1 (GIS) Zeolite Using Rice Husk

Short-period synthesis of high specific surface area silica from rice husk char

Comparative Study of Different Pretreatment and Combustion Methods on the Grindability of Rice-Husk-Based SiO<sub>2</sub>

Simultaneous Synthesis of Silica Polymorphs and Activated Carbon from Rice Husk

Fabrication of mesoporous silica nanoparticles by sol gel method followed various hydrothermal temperature