Abstract:In this study, the rice husk (RH) of "Joha rice" a unique rice variety of Assam (Northeast India) has been used as raw materials for synthesis of ash and silica powder. The combustion of the husk at 500°C for 1 h followed by further treatment at 800°C for 2 h in muffle furnace produces white rice husk ash (RHA). One part of RHA was kept as untreated, and the another part was acid treated. Silica was extracted from the untreated ash in the form of sodium silicate by treating with 2.5M NaOH at the boiling temperature. Then, silica was precipitated from sodium silicate by slow addition of 2.5M H 2 SO 4 . The broad x‐ray diffraction (XRD) pattern and characteristic peaks at d‐spacing, 8.3792 and 4.1489 with specific 2θ at ∼21.3° reveal the presence of amorphous SiO 2 as major phase in the ash (both acid treated and untreated). The characteristic Fourier transform infrared (FTIR) spectroscopic peaks at 470–450, 801, and 1100 cm −1 for different modes of Si‐O‐Si vibrations also support the presence of silica. The scanning electron micrographs (SEMs) revealed the morphology of the RHA as fine particles undergoing agglomeration probably due to hydrogen bonding between surface silanol groups present. The irregular rough morphology is a characteristic of the amorphous nature of the samples. The energy‐dispersive X‐ray analysis (EDX) showed that RHA composition was dominated by elements Si and O for both untreated and acid‐treated samples. For acid‐treated sample, the amount of Si and O is found to be comparatively higher than the untreated one due to surface cleaning. The point of zero charge (pH PZC ) of the prepared samples was determined by a simple pH metric method. The pH PZC of the untreated RHA was found to be ∼ 9.8 ± 0.2. However, almost similar pH PZC values of the acid‐treated RHA silica and commercial silica (∼6.6 ± 0.2) indicate the effectiveness of acid treatment prior processing.

Synthesis of Rice Husk Nanosilica using the Hydrothermal Method

Fabrication of mesoporous silica nanoparticles by sol gel method followed various hydrothermal temperature

A Detailed Study of the Effects of Pyrolysis Temperature and Feedstock Particle Size on the Preparation of Nanosilica from Rice Husk

SYNTHESIS OF NANO-SILICA FROM LOA KULU RICE HUSK USING THE SOL-GEL METHOD

Preparation of highly dispersed nanosilica from rice husk by aprecipitation method combined with high pressure homogenization

A novel two-staged thermal synthesis method of generating nanosilica from rice husk via pre-pyrolysis combined with calcination

Synthesis of silica and carbon-based nanomaterials from rice husk ash by ambient fiery and furnace sweltering using a chemical method

Simultaneous Synthesis of Silica Polymorphs and Activated Carbon from Rice Husk

Processing and Characterization of Nano Silica and Iron Oxide Coated Silica Composites Extracted from Rice Hulls

Synthesis and characterization of mesoporous silica nanoparticles (MSNp) MCM 41 from natural waste rice husk

Effect of temperature on the ability to synthesize SiC from rice husks

Synthesis and Characterisation of Nano-silica Based on Pumice Using NaOH

Synthesis of White Silica From "Joha Rice Husk" (A Special Rice Variety of Assam, India), Characterization and Determination of Its Point of Zero Charge (pH PZC )

A Comparative Study on Rice Husk, as Agricultural Waste, in the Production of Silica Nanoparticles via Different Methods

Chemical and structural properties of silica obtained from rice husk and its potential as a catalytic support

Optimization of Amorphous Silica Nanoparticles Synthesis from Rice Straw Ash Using Design of Experiments Technique

Improvement of the characteristics of silica particles extracted from rice husks using chemical-physical method

Synthesis of Pure-Silica Mtw Powder and Supported Films

Hydrothermal synthesis and characterization of fibrous silicananospheres

Synthesis and Characterization of Na-P1 (GIS) Zeolite Using Rice Husk

Effect of Temperature and Method of Synthesis on Morphology and Phase Transition of Amorphous and Crystalline Nano Silica Extracted from Mission Grass (Pennisetum Polystachion)