Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Surface Channel Hot-Carrier Effect on CLC N-Tfts

Surface-Channel Drain-Avalanche Hot-Carrier Effect under Temperature Variation on CLC TFTs

Degradation Mechanism for Continuous-Wave Green Laser-Crystallized Polycrystalline Silicon N-Channel Thin-Film Transistors under Low Vertical-Field Hot-Carrier Stress with Different Laser Annealing Powers

Trend transformation of drain-current degradation under drain-avalanche hot-carrier stress for CLC n-TFTs

Investigation on Hot-Carrier-induced Degradation of SOI NLIGBT.

Probing Drain Current with Vertical and Horizontal Electrical Fields under Temperature Stress on Clc Tfts

Research of Hot-carrier-induced Degradation on SOI NLIGBT

Instability Effect on CLC nTFTs with Positive-Bias Temperature Stress

Gate-to-drain Capacitance Verifying the Continuous-Wave Green Laser Crystallization N-Tft Trapped Charges Distribution under Dc Voltage Stress

Abnormal ${C}$ – ${V}$ Hump Effect Induced by Hot Carriers in Gate Length-Dependent P-Type LTPS TFTs

Surface Engineering of Polycrystalline Silicon for Long-Term Mechanical Stress Endurance Enhancement in Flexible Low-Temperature Poly-Si Thin-Film Transistors.

Visible Light Source Disturbing the Source/Drain Current of CLC Poly-Si N-Tft Device

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Impact of Stress Induced by Stressors on Hot Carrier Reliability of Strained Nmosfets

Analysis of abnormal threshold voltage shift induced by surface donor state in GaN HEMT on SiC substrate

Characteristics and hot-carrier effects of strained pMOSFETs with SiGe channel and embedded SiGe source/drain stressors

Degradation Mechanism of Short Channel P- FinFETs under Hot Carrier Stress and Constant Voltage Stress

Performance of Surface Carrier Mobility for Nano-Node Strained (110) MOSFETs with Temperature Effect

Low-Temperature-Processed Polycrystalline Silicon Thin-Film Transistors with Stable Solid-State Continuous-Wave Laser Crystallization

Characteristics and hot-carrier effects of strained pMOSFETs with SiGe channel and embedded SiGe source/drain stressor

Impact of AC Stress in Low Temperature Polycrystalline Silicon Thin Film Transistors Produced With Different Excimer Laser Annealing Energies