Abstract:In this study, the cooperative effect of Mg and Si contents on the microstructural evolution, mechanical properties, and deformation behavior of the cast Al–Li–Mg–Si alloys is investigated. Five different Al–Li–Mg–Si alloys are prepared by conventional casting method, which are referred to as Alloy A-E. The results show that with the increase in the Mg content, the amount of lath-like Mg2Si precipitates and bulk-like AlLiSi particles increases, which leads to an improvement in the strength and ductility of alloys. The amount of intergranular Si-rich phases in Alloy D increases with the increase in the Si content. Further, a higher Si content in Alloy E promotes the formation of bulk-like AlLiSi. The geometric phase analysis (GPA) results reveal strain partitioning behavior at the interface of Mg2Si precipitates and AlLiSi particles, which follows the Orowan looping or dislocation cutting strengthening mechanism. The geometrically necessary dislocation (GND) density calculation results suggest that the lath-like Mg2Si precipitates play a critical role in the deformation behaviors of Alloy A-C. The hindering effect of lath-like Mg2Si precipitates on the movement of dislocations decreases the GND density gap between high-angle grain boundaries or junctions and grain interior and improves the resistance to deformation. However, the deformation behaviors of Alloy D and E with higher Si content are mainly governed by the intergranular Si-rich phases. Finally, a methodological framework is established to elucidate the effect of precipitates and/or intergranular phases on the deformation behaviors of materials using a combination of GPA and GND density calculation methods.

Heterogeneous nucleation of Mg2Si on CaSb2 nucleus in Al–Mg–Si alloys

Heterogeneous Nucleation of Mg2Si on Sr11Sb10 Nucleus in Mg–x(3.5, 5 Wt.%)si–1al Alloys

One-Step Synthesis of Spherical Primary Mg2Si in Ca/Sb-Modified Al-Mg2Si Alloy

Influence of Li2sb Additions on Microstructure and Mechanical Properties of Al-20mg(2)Si Alloy

Effect of Mg on Nucleation Process of Recrystallization in Al–Mg–Si/SiCp Composite

Modification of Primary Mg2si in Mg-4si Alloys with Antimony

Investigation on morphology of primary Mg2Si in Al-20wt.%Mg2Si composite with experiment and first-principle calculations

The Effect of Solution Treatment on the Si Particles’ Morphology Evolution and the Thermal Conductivity and Tensile Properties of Sb-Modified Al-8Si-0.6Mg Alloys

Microstructure control and performance evolution of hypereutectic Al–20Mg2Si alloy by novel Al–Ca–Sb master alloy

Effect of SiC Particle Addition on Microstructure of Mg2Si/AI Composite

Formation of Equiaxed Crystal Structures in Directionally Solidified Al-Si Alloys Using Nb-based Heterogeneous Nuclei

Super-gravity field assisted homogeneous distribution of sub-micron eutectic Si in Al-Si alloy

Effect of Sb on Modification of Primary Mg_2Si Crystal in Hypereutectic Mg-Si Alloy

Regulative Effect of Mg/Si Ratio on Microstructure Evolution and Mechanical Properties of Cast Al-Li-Mg-Si Alloys

Microstructure Refinement of Mg-Al-Zn-Si Alloys

Effects of Si Content and Modification on Microstructure and Properties of In-situ Mg2Si/Mg Composites

Structural Evolution, Mechanical Properties, and Electronic Structure of Al–Mg–Si Compounds from First Principles

Effects of Doping Atoms (sb, Te, Sn, P and Bi) on the Equilibrium Shape of Mg2Si from First-Principles Calculations

Accelerating pore nucleation and eutectic Si growth kinetics by increasing Cu and Sc for Al-Si-Mg alloys: In-situ observation

Cooperative Effect of Mg and Si Contents on the Microstructural Evolution, Mechanical Performance, and Deformation Behavior of Cast Al–Li–Mg–Si Alloys

Machine learning-augmented modeling on the formation of Si-dominated Non- β′′ early-stage precipitates in Al-Si-Mg alloys with Si supersaturation induced by non-equilibrium solidification