Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Experimental study on the effect of wall-subcooling on condensation heat transfer in the presence of noncondensable gases in a horizontal tube

Experimental study of the effect of non-condensable gases on steam condensation over a vertical tube external surface

Reference temperature correction and dimensionless number analysis for heat transfer of supercritical CO2 in horizontal tubes

Numerical study on the condensation characteristics of vapor with non-condensable gas on inclined walls inside containment

Theoretical and Experimental Analyses of Two-Phase Flow Condensation Heat Transfer Inside the Horizontal Micro-Fin Tube

Research of humid air condensation heat transfer across the vertical wall

Experimental Study Of Condensation Flow Inside Horizontal Smooth, Herringbone And Three Enhanced Surface Tubes

Study of Heat Transfer for Co2 Flow Boiling in Horizontal Small Diameter Tubes

Experimental Study of Flow Boiling Instabilities in Horizontal Tubes under Gas–liquid Stratification Condition: Effects of Heat Flux and Inlet Subcooling Degree

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Visualization study of the influence of non-condensable gas on steam condensation heat transfer

Experimental study on condensation heat transfer characteristics of R410A in short vertical tubes

Experimental Study of the Moist Air Condensation Across a Vertical Cold Wall

Condensation heat and mass transfer of steam with non-condensable gases outside a horizontal tube under free convection

Heat transfer characteristics in vertical tube condensers: Experimental investigation and numerical validation

Condensation Heat Transfer Characteristics of Vapor Flow in Vertical Small-Diameter Tube with Variable Wall Temperature

Experimental Research on Condensation Outside A Horizontal Tube at Low Mass Fluxes

Experimental Investigation on Cooling Heat Transfer and Buoyancy Effect of Supercritical Carbon Dioxide in Horizontal and Vertical Micro-Channels

Theoretical Modeling of Vapor Condensation in the Presence of Noncondensable Gas on a Horizontal Tube

Effects of Condensation of Water Vapor of Wet Flue Gas on Convection Heat Transfer in Vertical Tubes

Experimental study on the effect of wall roughness on heat transfer characteristics of supercritical carbon dioxide in vertical tubes