Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Research of humid air condensation heat transfer across the vertical wall

Laminar forced convection heat and mass transfer of humid air across a vertical plate with condensation

Experimental Study of the Moist Air Condensation Across a Vertical Cold Wall

Numerical Study of the Forced Convective Condensation on a Short Vertical Plate

Theoretical and Experimental Study of Condensation Rates on Radiant Cooling Surfaces in Humid Air

Numerical Simulation of Wall Condensation from a Superheated Steam and Air Mixture in a Vertical Pipe

Heat transfer characteristics in vertical tube condensers: Experimental investigation and numerical validation

Visualization study of the influence of non-condensable gas on steam condensation heat transfer

Experimental study of the effect of non-condensable gases on steam condensation over a vertical tube external surface

Effects of Condensation of Water Vapor of Wet Flue Gas on Convection Heat Transfer in Vertical Tubes

Theoretical and Experimental Analyses of Two-Phase Flow Condensation Heat Transfer Inside the Horizontal Micro-Fin Tube

Condensation heat transfer between a vertical superhydrophobic aluminum surface and moist air under natural convection

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube

Numerical Simulations of Laminar Film Condensation of H2O/Air or H2O/CO2 on a Vertical Plate

Laminar film condensation heat transfer on a vertical, non-isothermal, semi-infinite plate

Lattice Boltzmann Modeling of Condensation Heat Transfer on Downward-Facing Surfaces with Different Wettabilities

Experimental Investigation of Indoor Air Flows in a Model Room

Research on Convective Condensation Heat Transfer for a Gas Mixture in a Vertical Tube

Experimental study on condensation heat transfer characteristics of R410A in short vertical tubes

Numerical Investigation of Air-Steam Condensation in a Vertically Enhanced Tube with Concave and Convex Surfaces