Abstract:Autothermal reforming (ATR) is an important technology for hydrogen production from natural gas, where soot formation deserves particular attention as it may cause catalyst poisoning. The typical configuration of ATR reactors is that of an inverse diffusion flame (IDF). In this study, soot formation near ATR condi-tions is investigated experimentally and numerically, focusing on the effects of pressure and CO2 dilution in IDFs with pressure reaching 5 bar. The fuel stream consists of methane diluted with CO2 or N2. The mole fraction of O2 in the oxidant stream is 70%. Polycyclic aromatic hydrocarbons (PAHs) and soot vol -ume fraction are measured by the planar laser-induced fluorescence (PLIF) and planar laser-induced in-candesce (PLII) methods. High-fidelity simulations with a detailed soot aerosol model are also performed, and an empirical reactive soot inception model is proposed. A comparison of the results shows that the soot behavior is well predicted by the empirical reactive inception model but not fully captured by the physical inception model based on irreversible dimerization, demonstrating the importance of radical in-volvement in the soot inception process. Both measurements and predictions show a linear relationship between peak soot volume fraction and pressure, which can be explained by the linear increase of PAH molar concentration with pressure. Simulation analysis indicates that the dimer adsorption and HACA mechanism have a similar quantitative contribution to the soot growth. The CO2 shows stronger suppres-sion effects in soot formation at the investigated pressures compared to N2. The contributions of chemical and thermal effects to soot suppression are numerically analyzed and the results indicate that the chem-ical effect of CO2 is mainly due to the removal of H radicals through the reaction CO2 + H & RARR; CO + OH, providing a soot suppression contribution of two times larger compared to the thermal one.& COPY; 2023 The Combustion Institute. Published by Elsevier Inc. All rights reserved.

Investigation of the Effect of Molecular Structure on Sooting Tendency in Laminar Diffusion Flames at Elevated Pressure

Measurements of sooting tendency in laminar diffusion flames of n-heptane at elevated pressure

Effect of Pressure and CO2 Dilution on Soot Formation in Laminar Inverse Coflow Flame at Conditions Close to Autothermal Reforming

Study of soot formations in co-flow laminar diffusion flames of n-heptane and oxygenated aromatic biofuels from atmospheric condition to 2.3 bar

Coupling Effects of Elevated Pressure and Preheating Temperature on Sooting Tendency in Laminar Co-Flow Diffusion Flame of N-Heptane

Experimental and Kinetic Study of Laminar Flame Characteristics of H2/O2/diluent Flame under Elevated Pressure

Structure And Sooting Limits In Counterflow Methane/Air And Propane/Air Diffusion Flames From 1 To 5 Atmospheres

The Effect of Flame Structure on Soot Formation and Transport in Turbulent Nonpremixed Flames Using Direct Numerical Simulation

Effect of gravity and pressure on soot formation in laminar inverse diffusion flames at elevated pressures

Experimental study on correlation between PAHs and soot in laminar co-flow diffusion flames of n-heptane at elevated pressure

Soot Concentration and Temperature Measurements in Co-flow Laminar Propane-Air Diffusion Flames at Pressures Up to 7 Bar

Experimental and numerical investigation on soot formation characteristics in n-decane diffusion flames at elevated pressures

Measurement of soot primary particle size in co-flow laminar diffusion flames of n-heptane at elevated pressures

Experimental and numerical research on the effects of pressure and CO2 dilution on soot formation in laminar co-flow methane/air diffusion flames

Soot Formation in Counterflow Ethylene Diffusion Flames from 1 to 2.5 Atmospheres

Study on Laminar Burning Characteristics of Premixed High-Octane Fuel−Air Mixtures at Elevated Pressures and Temperatures

PAHs and Soot Formation in Laminar Partially Premixed Co-Flow Flames Fuelled by PRFs at Elevated Pressures

Experimental and numerical study of the effect of elevated pressure on laminar burning velocity of lean H2/CO/O2/diluents flames

Laminar Flame Speeds of C5 to C8 N-Alkanes at Elevated Pressures and Temperatures

MORPHOLOGY AND BURNING RATES OF EXPANDING SPHERICAL FLAMES IN H 2 / O 2 / INERT MIXTURES UP TO 60 ATMOSPHERES

An Optical Study on Liquid-Phase Penetration, Flame Lift-off Location and Soot Volume Fraction Distribution of Gasoline–diesel Blends in a Constant Volume Vessel