Abstract:Preheating technology is widely used to improve the emission or efficiency of combustors, such as diesel engines and gasifiers operating at high pressures. Soot is an unwanted by-product, but its formation is unavoidable in high-pressure diffusion combustion. In this study, the effect of preheating temperature on polycyclic aromatic hydrocarbon (PAH) and soot formation in methane/air co-flow flames was comprehensively investigated in the pressure range of 1–5 bar. The temperature of inlet gas ranges from 295 K to 573 K. The soot, PAH, and OH* concentrations were obtained using planar laser-induced incandescence, planar laser induced fluorescence, and chemiluminescence techniques, respectively. The experimental results reveal that soot and PAH formation is greatly enhanced at higher pressure or with a higher preheating temperature of inlet gas. At a fixed preheating temperature, the peak/integrated soot volume fraction follows a power law with pressure. As pressure increases, the enhancement of soot formation by preheating temperature is suppressed. As the preheating temperature is raised from 295 K to 573 K, the integrated soot volume fraction is increased by 33.7 times at 1.5 bar, but the difference narrows to 2.3 times at 5 bar. OH* signal increases with preheating temperature at 1 bar, but the difference becomes indistinguishable at higher pressure. Further, the experimental results were utilized to evaluate the soot modeling, PAH and soot formation under experimental conditions are examined using four different kinetic mechanisms. While the soot trend along different pressure and preheating temperature is qualitatively captured, the quantitative predictions vary depending on the mechanisms. Specifically, KAUST and Narayanaswamy-Blanquart-Pitsch (NBP) mechanisms overpredict the soot volume fraction while DRL and Appel-Bockhorn-Frenklach (ABF) mechanisms underpredicts the soot volume fraction. In terms of the PAH spatial distribution, only DRL and ABF mechanisms show the ability to capture the experimental observations, that is the peak PAH appears in the flame centerline. The reaction pathway analysis indicates both fuel-pyrolysis chemistry and PAH growth chemistry should be accounted for the discrepancy.

Effect of gravity and pressure on soot formation in laminar inverse diffusion flames at elevated pressures

Effect of Pressure and CO2 Dilution on Soot Formation in Laminar Inverse Coflow Flame at Conditions Close to Autothermal Reforming

Assessment of Physical Soot Inception Model in Normal and Inverse Laminar Diffusion Flames

The Effects of CO2/CH4 Ratio on Soot Formation for Autothermal Reforming of Methane at Elevated Pressure

Experimental and Kinetic Study of the Effects of CO2 and H2O Addition on PAH Formation in Laminar Premixed C2H4/O2/Ar Flames

Chemical Suppressive Effect of Ammonia Addition on Soot Formation in Laminar Diffusion Flames

Chemical Mechanism of Exhaust Gas Recirculation on Polycyclic Aromatic Hydrocarbons Formation Based on Laser-Induced Fluorescence Measurement

Soot production in high pressure inverse diffusion flames with enriched oxygen in the oxidizer stream

Effect of Dimethyl Ether (DME) Addition on Sooting Limits in Counterflow Diffusion Flames of Ethylene at Elevated Pressures

Experimental and numerical investigation on soot formation characteristics in n-decane diffusion flames at elevated pressures

PAHs and Soot Formation in Laminar Partially Premixed Co-Flow Flames Fuelled by PRFs at Elevated Pressures

Effect of pressure and CO 2 dilution on soot formation in laminar inverse coflow flame at conditions close to autothermal reforming

Experimental and numerical research on the effects of pressure and CO2 dilution on soot formation in laminar co-flow methane/air diffusion flames

Large Eddy Simulation of Soot Formation in a Turbulent Lifted Flame with a Discretized Population Balance and a Reduced Kinetic Mechanism

Soot Formation in Counterflow Ethylene Diffusion Flames from 1 to 2.5 Atmospheres

Numerical Study of Soot Formation in Laminar Coflow Diffusion Flames of Methane Doped with Primary Reference Fuels

Study of soot formations in co-flow laminar diffusion flames of n-heptane and oxygenated aromatic biofuels from atmospheric condition to 2.3 bar

Experimental study on correlation between PAHs and soot in laminar co-flow diffusion flames of n-heptane at elevated pressure

Soot Concentration and Temperature Measurements in Co-flow Laminar Propane-Air Diffusion Flames at Pressures Up to 7 Bar

The effect of preheating temperature on PAH/soot formation in methane/air co-flow flames at elevated pressure

Effect of Oxygen Contents on Morphology, Nanostructure, and Its Formation of Soot in Laminar Coflow Ethylene-Ammonia Diffusion Flames