Abstract:The main part of oil‐immersed power equipment is oil‐paper insulation. At lower ambient temperatures, transformer oil will become viscous. As a result, compared to those at room temperature or operating temperature, the frequency domain dielectric properties of oil‐paper insulation at low temperatures are drastically different. For evaluating the insulation condition of electrical equipment, it is essential to accurately determine their dielectric properties. This paper described the FDS test, the DC conductivity test, and the transformer oil viscosity test, which was carried out in a laboratory environment for different ageing of oil‐immersed pressboard and transformer oil at 233–373 K. The effects of temperature on the dielectric properties at the competing mechanisms of polarisation and conductivity loss were clarified based on variations of the FDS curves. Considering the viscosity change of ageing transformer oil at low temperatures, the Arrhenius and VFT viscosity equations were used to achieve a fitting calculation in the different temperature zones. Based on the molecular/ion transition model in the force field and electric field, the characterisation relationships between the dynamic viscosity, DC conductivity, and test temperature of transformer oil were established. The limitations of conventional transformer oil equivalent dielectric relaxation models over a wide temperature range were finally clarified by combining the test findings of the DC conductivity over a wide temperature range with observed and simulated calculations. This paper provides an essential theoretical reference when using the FDS test to diagnose the insulation performance of oil‐immersed power equipment in extremely cold regions.

Notice of Retraction The influence of heavy load to the dielectric loss factor measure and the improvement

Frequency Parameter Identification and Impact Analysis of Load Based on Measured Data

Improvements and measurements of parameter identification for electric load

Analysis of Conductor Loss in Interdigital Capacitor Based Measurement of Dielectric Constant of Ferroelectric Thin Film

Evaluation of the Calculation Method for Stray Losses in Structural Parts of HVDC Converter Transformers

Calculation Method of Winding Eddy-Current Losses for High-Voltage Direct Current Converter Transformers

A Loss Measurement Approach of Power Magnetic Components under Practical Power Electronics Conditions

Investigation on Steady State Characteristics and Loss Reduction Measures of 220 Kv Power Cables

Investigation on Loss Reduction Strategies of Single-Core HVAC Submarine Cables

Sheath Loss Calculation and Loss Reduction Analysis of 220 Kv Cable System

Dielectric Loss Measurement Method Based on Quasi-synchronous DFT

Notice of Retraction Analysis of low-electrode displacement effect on standard high-voltage compressed gas capacitor

A method of measuring dielectric loss of current transformer by changing frequency

A DC Differential Method for Core Loss Measurement under Sinusoidal Excitation

Research on the variation of dielectric properties of oil‐paper insulation for power equipment over a wide temperature range

Dielectric loss and partial discharge test analysis of 10 kV XLPE cable

A new on-line insulation diagnostic method for capacitive-type equipment

On-site FDS Test Analysis and Countermeasure Strategy Discussions of Oil-impregnated Paper Condenser Bushing

Research on Voltage an Temperature Influence characteristics of Frequency Domain Dielectric Spectrum of Dry-type Epoxy Resin impregnated Paper Insulating Bushings

Principle and Application of the Contactless Load Detection Based on the Amplitude Decay Rate in A Transient Process

Analysis of Traction Reflux Characteristics of EMU and Improvement of Its Protective Grounding System