Abstract:Helically coiled tubes are employed as heat transfer tubes in Once Through Steam Generator (OTSG) of High Temperature Gas-cooled Reactor (HTGR) due to their compact structure, large heat transfer area and excellent thermal expansion adaptability. However, the helical geometry induces centrifugal forces and secondary flows in the tube, resulting in notable differences in flow and heat transfer characteristics compared to that of straight tubes. This study conducted an experimental investigation on the onset of nucleate boiling (ONB) and the subcooled boiling heat transfer coefficient in helically coiled tubes with a large curvature ratio (δ = 0.109). The experimental parameters cover broad ranges. The system pressures are ranging from 3.5 to 7 MPa, mass fluxes are from 300 to 1100 kg/(m2·s) and heat fluxes are from 50 to 600 kW/m2. The experimental results indicate that the ONB can occur even when the average inner wall temperature is below the fluid’s saturation temperature. An increase in heat flux advances the ONB, while increases in mass flux and system pressure delay it. Enhancements in both heat flux and mass flux improve the subcooled boiling heat transfer coefficient. Additionally, higher system pressure also increases the heat transfer coefficient, although this effect diminishes as the quality increases. Based on the experimental data and dimensionless analysis, new correlations were proposed for predicting ONB and calculating the subcooled boiling heat transfer coefficient in helically coiled tubes. Both new correlations exhibit more accurate predictive capabilities, with mean absolute percentage error (MAPE) values of 6.20 % and 8.86 %, respectively.

Forced Convection Boiling Heat Transfer and Dryout Characteristics in Helical Coiled Tubes with Various Axial Angles

Dryout characteristics in horizontal helically coiled tube

Investigation of Flow Boiling Heat Transfer Characteristics of CO2in Horizontal Mini-Tube

Experimental Investigation of Forced Convective Boiling Flow Instabilities in Horizontal Helically Coiled Tubes

Experimental Study of Single and Two-Phase Flow and Heat Transfer Characteristics in Helical Tube under Motion Condition

Study On Heat Transfer Of High-Pressure Steam-Water Two-Phase Mixture In Helical Coils

Experimental Investigation of Subcooled Flow Boiling Characteristics of Water in Vertical Helically Coiled Tubes

Study of Heat Transfer for Co2 Flow Boiling in Horizontal Small Diameter Tubes

Convective Boiling Heat Transfer and Two-Phase Flow Characteristics Inside A Small Horizontal Helically Coiled Tubing Once-Through Steam Generator

Experimental study on friction pressure drop and circumferential heat transfer characteristics in helical tubes

The frictional pressure drop of steam-water two-phase flow during forced convective boiling inside a small horizontal helical coil tube

Numerical Simulation on Heterogeneous Heat Transfer in Water at Supercritical Pressures in Inclined Upward Tubes

Nonuniform Heat Transfer in Horizontal Helical Coils Tube Steam Generators

An Investigation on Heat Transfer Characteristics of Different Pressure Steam-Water in Vertical Upward Tube

Experimental Investigation on Heat Transfer Characteristics of Water in Inclined Downward Tube of A Supercritical Pressure Cfb Boiler

An experimental investigation of oscillatory heat transfer in helical coiled tube with steam water two phase density wave oscillation flow

Experimental Investigation of Pressure Drop Oscillations of Steam Water Two Phase Flow in Helically Coiled Tubing Boiler Reactors

An Assessment of Heat Transfer Models of Water Flow in Helically Coiled Tubes Based on Selected Experimental Datasets

Experimental investigation on the convective boiling flow instabilities of steam/water two phase flow in horizontal helically coiled tube

AN EXPERIMENTAL INVESTIGATION OF OSCILLATORY HEAT TRANSFER IN HELICAL COILED TUBE WITH STEAM WATER TWOPHASE DENSITY WAVE OSCILLATION FLOW

Flow boiling heat transfer characteristics in vertical upward internally ribbed tube