Abstract:In order to investigate the boundary characteristics of density wave oscillations in nuclear reactor steam generators and boiler water-cooled wall tubes, a frequency domain method numerical calculation model applicable to different geometrical structures and operating parameters was developed. In order to make the results of the model more accurate, the state of the fluid at the outlet of the heated pipe and the time delay were fully considered on the basis of the traditional model. Depending on the physical properties of the fluid at the outlet of the heated pipe, the model calculation area was divided into single-phase, two-phase and superheated zones. Small-perturbation linearization and Laplace transform were performed on the conservation equations in the three regions. The Nyquist stability criterion was used in matlab software to judge the stability of the flow, and by varying the working parameters the flow instability boundary can be calculated. For a more in-depth study of density wave oscillations in heated pipes, the unstable boundary characteristics were analysed computationally for different influences such as pressure, mass flow rate, inlet subcooling degree and pipe geometry on the basis of model validation. In addition, the Nyquist function was used in Matlab to plot the Nyquist curve for different influencing factors and to analyse the stability margins for specific operating conditions. The unstable boundary characteristic diagram was obtained when the pressure was 5–10 MPa and the mass flux was 300–1300 kg·m −2 ·s −1 . The calculated data was collated and mass flow rate and heat load boundary diagrams were plotted, which could visualise the boundary characteristics of the density wave oscillations under different operating conditions. In order to make the calculation results more applicable, N sub and N pch were used to construct the dimensionless unstable boundary characteristic diagram. Results showed that the influence of inlet subcooling degree on flow stability is non-monotonic. In addition, the effects of factors such as pressure, mass flow rate and inlet throttling coefficient are monotonic.

Experimental investigation on the convective boiling flow instabilities of steam/water two phase flow in horizontal helically coiled tube

Experimental Study of Flow Boiling Instabilities in Horizontal Tubes under Gas–liquid Stratification Condition: Effects of Heat Flux and Inlet Subcooling Degree

AN EXPERIMENTAL INVESTIGATION OF OSCILLATORY HEAT TRANSFER IN HELICAL COILED TUBE WITH STEAM WATER TWOPHASE DENSITY WAVE OSCILLATION FLOW

Experimental Research on Fluid-Elastic Instability of Tube Bundles Subjected to Two-Phase Cross Flow

Two-phase Flow Oscillation and Distribution in Parallel Channels During R1233zd(E) Subcooled Flow Boiling: A Numerical Study

Experimental study on two-phase flow instability in helically coiled tube under rolling motion

Regulation of Gas-Liquid Stratified Flow Boiling Dynamic Instabilities in Horizontal Tube: Effects of Heat Load Distribution and Wall Thermal Capacity

Visualized Investigation of the Onset of Flow Boiling Dynamic Instabilities in a Horizontal Arranged Tube under a High-Temperature Thermal Storage Boundary Condition

EXPERIMENTAL INVESTIGATION AND FLOW VISUALIZATION OF THE TWO-PHASE FLOW INSTABILITY AT LOW VAPOR QUALITY IN A VERTICAL NARROW CHANNEL

Investigation of Flow Boiling Heat Transfer Characteristics of CO2in Horizontal Mini-Tube

Numerical study on acoustic characteristics of flow boiling in a helical tube

Two-Phase Flow Instability of Boiling in A Double Microchannel System at High Heating Powers

Visualized Investigation of Gas–liquid Stratified Flow Boiling of Water in a Natural Circulation Thermosyphon Loop with Horizontal Arranged Evaporator

Transient Numerical Simulation and Two-phase Flow Instability Prediction of Convective Boiling in Vertical Up-flow Tube

Experimental Study of Two-Phase Flow Oscillation in Natural Circulation

Numerical study on flow instability in parallel helical tubes under ocean conditions

The Analysis of Two-Phase Flow Instability in a Vertical U-tube Evaporator

Frequency domain analysis of density wave oscillations for two-phase flow in a vertical tube

Two-phase flow boiling instabilities: A review

COMPARISON OF FLOW INSTABILITY CRITERIA AND THRESHOLD CALCULATION METHODS OF DENSITY WAVE OSCILLATIONS IN A VERTICAL BOILING CHANNEL

Investigation of Flow and Heat Transfer Instabilities and Oscillation Inhibition of N-Decane at Supercritical Pressure in Vertical Pipe